40 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
03V284000 · Equipment:Other:Labels
Reported: 2003-08-01 (August 1, 2003) · Model years: 2001, 2002, 2003
CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE SECOND ISOFIX GUIDE WAS NOT INSTALLED IN THESE VEHICLES AND, IN CERTAIN CASES, THE OWNER'S MANUAL ISOFIX INFORMATION IS INCORRECT.
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL RECEIVE A LETTER/PACKAGE CONSISTING OF THE SECOND ISOFIX GUIDE WITH INSTALLATION INSTRUCTIONS, AND IN CERTAIN CASES, THE CORRECTED OWNER'S MANUAL MAY BE PROVIDED. IF THE OWNER WANTS TO TAKE THEIR VEHICLE TO A VOLVO DEALER FOR INSTALLATION OF THE GUIDE, IT WILL BE PERFORMED AT NO CHARGE TO THE OWNER. OWNER NOTIFICATION BEGAN ON DECEMBER 19, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
NHTSA campaign record ↗04V451000 · Engine And Engine Cooling:Cooling System:Fan
Reported: 2004-09-13 (September 13, 2004) · Model years: 2001
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Consequence: A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
NHTSA campaign record ↗06V441000 · Vehicle Speed Control
Reported: 2006-11-15 (November 15, 2006) · Model years: 2001, 2002
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
NHTSA campaign record ↗07V152000 · Fuel System, Gasoline:Delivery:Fuel Pump
Reported: 2007-04-05 (April 5, 2007) · Model years: 2001, 2002
ON CERTAIN VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA, DUE TO THE COMBINATION OF FUEL QUALITY AND CLIMATE CONDITIONS, THE FUEL PUMP MAY, IN CERTAIN CASES, EXPERIENCE A REDUCED FUNCTIONALITY. THE MOST COMMON SYMPTOMS WOULD BE FUEL ODOR.
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP FREE OF CHARGE. THE RECALL BEGAN ON JULY 10, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
NHTSA campaign record ↗09V483000 · Fuel System, Gasoline:Delivery:Fuel Pump
Reported: 2009-12-18 (December 18, 2009) · Model years: 2001, 2002, 2003, 2004
VOLVO IS RECALLING CERTAIN MODEL YEAR 2001-2005 S80, MODEL YEAR 2001-2004 V70, S60, XC70 AND MODEL YEAR 2003-2005 XC90 VEHICLES SOLD IN OR REGISTERED IN THE STATES OF ALABAMA, ARIZONA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, KENTUCKY, LOUISIANA, MISSISSIPPI, NEVADA, NEW MEXICO, NORTH CAROLINA, OKLAHOMA, SOUTH CAROLINA, TENNESSEE, TEXAS, UTAH, VIRGINIA AND THE U.S. TERRITORIES. WHEN EXPOSED TO CERTAIN ENVIRONMENTAL CONDITIONS (HOT CLIMATE AND TEMPERATURE CYCLING) OVER TIME AND IN COMBINATION WITH VARYING FUEL QUALITY, THE FUEL PUMP CAN DEVELOP CRACKS IN THE FUEL PUMP FLANGE.
Consequence: IF THE CONDITION OCCURS VEHICLE OWNERS MAY NOTICE FUEL SMELL AND/OR FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT THE FUEL PUMP INSTALLED IN THE VEHICLE, AND IF NECESSARY REPLACE THE FUEL PUMP WITH A PART OF A MODIFIED DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 15, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
NHTSA campaign record ↗10V566000 · Equipment:Electrical:Navigational System(Global Positioning System)
Reported: 2010-11-08 (November 8, 2010) · Model years: 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
NHTSA campaign record ↗20V681000 · Air Bags:Frontal:Driver Side:Inflator Module
Reported: 2020-11-04 (November 4, 2020) · Model years: 2001, 2002, 2003
Volvo Car USA LLC (Volvo Car) is recalling certain 2001-2003 S80 and S60 vehicles sold or ever registered in Alabama, Arkansas, Florida, Georgia, Hawaii, Louisiana, Mississippi, North Carolina, Oklahoma, South Carolina, Tennessee, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands. The driver side frontal air bag inflator may rupture, sending metal fragments into the passage compartment, when the driver side air bag is deployed.
Consequence: Metal fragments can strike vehicle occupants increasing the risk of serious injury or death.
Remedy: Volvo Car will notify owners, and dealers will replace the driver side air bag module, free of charge. The recall began April 20, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10058.
NHTSA campaign record ↗21V766000 · Air Bags:Frontal:Driver Side:Inflator Module
Reported: 2021-09-30 (September 30, 2021) · Model years: 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009
Volvo Car USA, LLC (Volvo Car) is recalling certain 2001-2006 S80 and 2001-2009 S60 vehicles. The driver's air bag inflator may explode during deployment, due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Dealers will replace the driver's air bag, free of charge. Owner notification letters were mailed November 29, 2021. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo's number for this recall is R10125.
NHTSA campaign record ↗03V305000 · Equipment:Other:Labels
Reported: 2003-08-21 (August 21, 2003) · Model years: 2002
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE PRESSURE LABEL IS INCORRECT. THESE VEHICLES DID NOT HAVE THE "MAX LOAD VEHICLE CAPACITY WEIGHT" INFORMATION ON THE LABEL.
Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy: OWNERS WILL BE PROVIDED WITH A CORRECTED LABEL. IF THE OWNER SO DESIRES, A DEALER CAN INSTALL THE LABEL FOR THEM. OWNER NOTIFICATION BEGAN ON DECEMBER 8, 2003. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
NHTSA campaign record ↗07V226000 · Engine And Engine Cooling
Reported: 2007-06-05 (June 5, 2007) · Model years: 2003, 2004
ON CERTAIN PASSENGER VEHICLES, THE FUEL PRESSURE SENSOR LOCATED ON THE LEFT END OF THE FUEL RAIL MAY, AT TIMES, TRANSMIT INCORRECT SIGNAL REGARDING THE FUEL PRESSURE TO THE ENGINE CONTROL MODULE. IF THE SIGNAL IS OUTSIDE OF THE PRE-PROGRAMMED ALLOWABLE LIMITS, A DIAGNOSTIC TROUBLE CODE MAY BE SET AND THE CHECK ENGINE LIGHT WILL COME ON. THE SOLDERED JOINTS ON THE CIRCUIT BOARD OF THE FUEL PRESSURE SENSOR MAY CRACK DUE TO TEMPERATURE CHANGES AND EXCESSIVE VIBRATIONS.
Consequence: MISFIRE MAY OCCUR DURING DRIVING THAT, IN TURN, WILL REDUCE THE ENGINE TORQUE AND IN THE WORST CASE SCENARIO, THE ENGINE MAY STALL WITHOUT WARNING. IN CERTAIN TRAFFIC SITUATIONS THIS COULD CAUSE AN UNSAFE SITUATION AND POSSIBLY A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL PRESSURE SENSOR FREE OF CHARGE. THE RECALL BEGAN ON JUNE 29, 2007. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
NHTSA campaign record ↗04V029000 · Steering:Linkages
Reported: 2004-01-16 (January 16, 2004) · Model years: 2004
ON CERTAIN PASSENGER VEHICLES, THE FRONT CONTROL ARMS MAY NOT HAVE BEEN MANUFACTURED CORRECTLY AND, AS A RESULT, THE STUD AND NUT THAT SECURE THE ARM TO THE SPINDLE MAY LOSE THEIR INITIAL AXIAL TENSION. UNDER CERTAIN DRIVING CONDITIONS, THE STEERING MAY BECOME LESS RESPONSIVE AND THE DRIVER MAY EXPERIENCE STEERING WHEEL PLAY.
Consequence: THIS DRIVING CONDITION COULD EVENTUALLY LEAD TO SEPARATION BETWEEN THE FRONT CONTROL ARM AND THE SPINDLE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL A NEW TYPE OF NUT. OWNER NOTIFICATION BEGAN ON FEBRUARY 16, 2004. OWNERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
NHTSA campaign record ↗06V375000 · Equipment:Other:Labels
Reported: 2006-10-03 (October 3, 2006) · Model years: 2005, 2006
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE LABEL DENOTING THE TIRE AND LOADING PRESSURE INFORMATION IS INCORRECT.
Consequence: A MISPRINTED LABEL WOULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL THE CORRECT LABELS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 18, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
NHTSA campaign record ↗10V591000 · Seats
Reported: 2010-11-22 (November 22, 2010) · Model years: 2009, 2011
VOLVO IS RECALLING CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER FRONT PASSENGER SEATS. THE FRONT SEAT RAIL'S DETECTION SYSTEM WAS MANUFACTURED INCORRECTLY AND MAY PERMIT THE PASSENGER TO FORWARD THE SEAT BEYOND THE INTENDED MAXIMUM.
Consequence: POSITIONING OF THE SEAT BEYOND THE INTENDED MAXIMUM CAN CAUSE INCREASED RISK OF INJURY TO THE PASSENGER IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE FRONT POWER SEAT STOPS FOR BOTH FRONT SEATS FOR THE PRESENCE OF AN "END STOP" AND REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 23, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT [email protected].
NHTSA campaign record ↗10V579000 · Engine And Engine Cooling
Reported: 2010-11-17 (November 17, 2010) · Model years: 2011
VOLVO IS RECALLING CERTAIN MODEL YEAR 2011, S80, S60, XC70 AND XC60 VEHICLES. THE SOFTWARE CALIBRATION FOR THE FUEL CUT-OFF FUNCTIONALITY IN THE ENGINE CONTROL MODULE (ECM) IS TOO SENSITIVE.
Consequence: SUDDEN ENGINE STALL COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL UPDATE THE ECM AND TCM WITH NEW SOFTWARE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE DECEMBER 10, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT [email protected].
NHTSA campaign record ↗11V508000 · Equipment:Other:Labels
Reported: 2011-10-18 (October 18, 2011) · Model years: 2011, 2012
VOLVO IS RECALLING CERTAIN MODEL YEAR 2006-2012 C70 VEHICLES MANUFACTURED FROM NOVEMBER 15, 2005, THROUGH JULY 31, 2011, AND MODEL YEAR 2011-2012 S60 VEHICLES MANUFACTURED FROM JULY 14, 2010, THROUGH APRIL 16, 2011, THAT WERE EQUIPPED WITH OPTIONAL ACCESSORY SPARE TIRE KIT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES DO NOT CONTAIN THE CORRECT INFORMATION FOR VEHICLES EQUIPPED WITH THE OPTIONAL ACCESSORY SPARE TIRE AND WHEEL KIT.
Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: VOLVO WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE VEHICLE AND INSTALL THE LABEL AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 23, 2012. OWNERS MAY CONTACT VOLVO AT 1-201-768-7300.
NHTSA campaign record ↗13V592000 · Engine And Engine Cooling:Engine
Reported: 2013-11-22 (November 22, 2013) · Model years: 2011, 2012
Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2011-2012 S60 vehicles manufactured June 22, 2010, through May 14, 2012, and equipped with 5-cylinder B5254T5 (VIN code 62) engines. In the affected vehicles, the vehicle may not alert the driver of a low oil pressure situation.
Consequence: Without being warned of a low oil pressure situation, the driver may continue to drive the vehicle until it stalls, which increases the risk of a crash.
Remedy: Volvo will notify owners, and dealers will update the vehicle's software so that the driver is alerted should there be a low oil pressure situation, free of charge. The recall began on January 10, 2014. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R29436.
NHTSA campaign record ↗19V849000 · Latches/Locks/Linkages:Doors:Latch
Reported: 2019-11-26 (November 26, 2019) · Model years: 2011, 2012, 2013, 2014, 2015, 2016, 2017
Volvo Car of USA LLC (Volvo) is recalling certain 2011-2017 S60, S60I, V60, S60CC and V60CC vehicles. A component within the door latches may break, making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Volvo will notify owners, and dealers will replace all four door latches, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89978.
NHTSA campaign record ↗20V378000 · Seat Belts:Front
Reported: 2020-06-30 (June 30, 2020) · Model years: 2011, 2012, 2013, 2014, 2015, 2016, 2017, 2018
Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.
Consequence: An unsecured occupant has an increased risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.
NHTSA campaign record ↗11V303000 · Fuel System, Gasoline:Delivery:Fuel Pump
Reported: 2011-06-01 (June 1, 2011) · Model years: 2012
VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60 PASSENGER CARS MANUFACTURED FROM NOVEMBER 18, 2010, THROUGH MAY 5, 2011. THE SOFTWARE FOR THE FUEL PUMP UNITS MAY NOT BE COMPATIBLE WITH ALL FUEL PUMPS AND COMPONENTS RESULTING IN INSUFFICIENT FUEL TRANSFER IN THE PUMP UNIT.
Consequence: UNDER CERTAIN DRIVING CONDITIONS, THERE MAY BE ENGINE HESITATION AND POSSIBLE ENGINE STALL EVEN THOUGH THE FUEL GAUGE INDICATES UP TO 1/4 OF THE FUEL IS LEFT IN THE TANK. THIS CONDITION INCREASES THE RISK OF A VEHICLE CRASH.
Remedy: VOLVO WILL NOTIFY OWNERS AND DEALERS WILL UPGRADE THE ENGINE CONTROL MODULE SOFTWARE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 1, 2011. OWNERS MAY CONTACT VOLVO AT 1-201-768-7300.
NHTSA campaign record ↗11V311000 · Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings
Reported: 2011-06-06 (June 6, 2011) · Model years: 2012
VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60 PASSENGER CARS MANUFACTURED FROM JANUARY 18, 2011, THROUGH JANUARY 28, 2011. THE MALE PART OF THE FUEL LINE QUICK CONNECTOR END SHAPE WAS PRODUCED WITH DIMENSIONS OUT OF SPECIFICATION, LEADING TO EXCESSIVE ASSEMBLY FORCE ON THE FEMALE CONNECTOR ASSEMBLY AND THE POSSIBILITY THAT THE LOCKING FUNCTION MAY NOT BE ENGAGED.
Consequence: IF A VEHICLE EXHIBITS THIS CONDITION, THE FUEL LINE QUICK CONNECTOR MAY DETACH AND THE ENGINE MAY STALL, INCREASING THE RISK OF A CRASH. THE CUSTOMER MAY ALSO NOTICE A FUEL SMELL AND LEAKAGE. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: VOLVO DEALERS WILL REPLACE THE FUEL LINES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 24, 2011. OWNERS MAY CONTACT VOLVO AT 1-201-768-7300.
NHTSA campaign record ↗12V075000 · Electrical System:Wiring
Reported: 2012-02-28 (February 28, 2012) · Model years: 2012
VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60, XC60, S80 AND XC70 VEHICLES MANUFACTURED FROM MAY 16, 2011, THROUGH OCTOBER 6, 2011. IN THESE VEHICLES, THE WIRE HARNESS UNDER THE FRONT SEATS MAY HAVE NOT BEEN ATTACHED PROPERLY TO THE SEAT FRAME. AS A RESULT, WHEN THE SEATS ARE MOVED TO ADJUST THE SEATING POSITION, THE WIRE HARNESS MAY GET PULLED, CAUSING IT TO DISCONNECT.
Consequence: IN THE EVENT OF CRASH, THE FRONT AND/OR SIDE IMPACT AIR BAGS MAY DEPLOY IMPROPERLY OR NOT AT ALL, INCREASING THE RISK OF INJURY. ALSO, THE LAP BELT PRETENSIONER MAY NOT DEPLOY.
Remedy: VOLVO WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND, IF NECESSARY, SECURE THE SEAT WIRE HARNESS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 12, 2012. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
NHTSA campaign record ↗12V101000 · Structure:Body
Reported: 2012-03-14 (March 14, 2012) · Model years: 2012
VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60 AND XC60 PASSENGER VEHICLES. AN INCORRECT MIXTURE OF UNDERBODY COATING AND OVER-APPLICATION CAN RESULT IN RIGID, ICICLE-LIKE AREAS HANGING FROM VEHICLES UNDERCARRIAGE.
Consequence: IF THIS CONDITION EXISTS, THE UNDERBODY COATING MAY PENETRATE THE FUELS LINES AND CAUSE FUEL LEAKAGE, INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSPECT THE VEHICLE UNDERCARRIAGE, AND IF EXCESSIVE UNDERBODY COATING IS FOUND IN THE FUEL LINE AREA, IT WILL BE REMOVED. IF THE INSPECTION REVEALS THAT THE FUEL LINES ARE DAMAGED, THEY WILL BE REPLACED. THE SAFETY RECALL BEGAN ON APRIL 25, 2012. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552.
NHTSA campaign record ↗12V439000 · Air Bags:Frontal:Sensor/Control Module-Inactive
Reported: 2012-09-10 (September 10, 2012) · Model years: 2013
Volvo is recalling certain model year 2013 S60 and XC60 vehicles. A manufacturing defect within the Supplemental Restraint System (SRS) control unit may lead to an inadvertent deployment of the seat belt pretensioner and/or inflatable curtain.
Consequence: If the seat belt pretensioner and/or inflatable side curtain deploy without cause, the driver could be distracted and the driver's visibility could be reduced, increasing the risk of a crash.
Remedy: These vehicles have not been sold and the SRS control unit will be replaced prior to the cars being sold. Owners may contact Volvo at 1-800-458-1552.
NHTSA campaign record ↗13V084000 · Equipment:Other:Labels
Reported: 2013-03-05 (March 5, 2013) · Model years: 2013
Volvo is recalling certain model year 2013 S60 and XC60 vehicles, manufactured on January 7, 2013. The product identification labels were printed with the incorrect manufacture year. Thus, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification Regulation."
Consequence: With an incorrect date of manufacture on the certification label, the vehicle owner may not be to determine if they are affected by future vehicle recalls, increasing their risk of a crash of injury.
Remedy: Volvo has quarantined the affected vehicles and will install correct labels prior to sale. The recall began during March 2013. Owner notification letters will not be sent.
NHTSA campaign record ↗13V377000 · Electrical System
Reported: 2013-08-21 (August 21, 2013) · Model years: 2014
Volvo is recalling certain model year 2014 S60, S80, XC60 and XC70 vehicles equipped with keyless ignition. In the affected vehicles, the Central Electronic Module (CEM) will not perform as intended. As a result, the front windshield wipers might run continuously when the ignition is on. Also, the turn signals, high beams, and headlight switch might not work.
Consequence: Malfunctioning head lamps and/or turn signals increase the risk of a crash.
Remedy: Volvo will notify owners, and dealers will upgrade the CEM software, free of charge. The recall began on October 3, 2013. Owners may contact Volvo at 1-800-458-1552.
NHTSA campaign record ↗15V555000 · Electrical System:Wiring:Fuses And Circuit Breakers
Reported: 2015-09-02 (September 2, 2015) · Model years: 2016
Volvo Cars of North America, LLC. (Volvo) is recalling certain model year 2016 Volvo S60, V60, V60CC, XC60, XC70, and S80 vehicles manufactured April 8, 2015 to August 19, 2015. In certain driving conditions when using the automatic engine stop/start function, the starter motor fuse may blow, preventing the car from restarting when necessary.
Consequence: If the vehicle is unexpectedly unable to be started in the middle of traffic, such as when stopped at an intersection, there is an increased risk of a crash.
Remedy: Volvo will notify owners, and dealers will replace the existing starter motor fuse with a higher amperage fuse, free of charge. The recall began on October 26, 2015. Owners may contact Volvo customer service at 1-800-458-1552 or by visiting http://volvo.custhelp.com. Volvo's number for this recall is R39574.
NHTSA campaign record ↗16V798000 · Seat Belts:Front:Buckle Assembly
Reported: 2016-11-02 (November 2, 2016) · Model years: 2016, 2017
Volvo Car USA LLC (Volvo) is recalling certain model year 2016-2017 XC90, S90, XC60, V60 Cross Country, V60, S60 Cross Country, S60, and S60 Inscription vehicles manufactured February 16, 2015, to August 22, 2016. On the affected vehicles, the front passenger seat belt buckle attaching stud may loosen, allowing the buckle to separate from the seat belt bracket. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages" and number 209, "Seat Belt Assemblies."
Consequence: If the seat belt buckle separates from the bracket, the front seat passenger may not be adequately restrained in the event of a crash, increasing their risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will inspect the front passenger seat belt buckle stud, replacing the seat belt buckle as needed, free of charge. The recall began January 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89708.
NHTSA campaign record ↗16V918000 · Air Bags
Reported: 2016-12-21 (December 21, 2016) · Model years: 2017
Volvo Car USA LLC (Volvo) is recalling certain model year 2017 S60 and S60 Cross Country, V60 and V60 Cross Country, and XC60 vehicles manufactured August 16, 2016, through October 21, 2016. The affected vehicles have driver and front passenger seat side mounted side air bags (SAB) with inflator initiators that may fail to ignite during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection" and number 214, "Side Impact Protection."
Consequence: If the air bag inflator initiator fails to ignite, the air bag will not deploy, increasing the risk of injury.
Remedy: Volvo will notify owners, and dealers will inspect and, if necessary, replace the front seat side air bags, free of charge. The recall is expected to begin on February 13, 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89712.
NHTSA campaign record ↗17V127000 · Air Bags
Reported: 2017-03-01 (March 1, 2017) · Model years: 2017
Volvo Car USA LLC (Volvo) is recalling certain 2017 S60, S60CC, V60, V60 Cross Country, and XC60 vehicles. The affected vehicles have driver and front passenger seat side mounted side air bags (SAB) with inflator initiators that may fail to ignite during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection" and number 214, "Side Impact Protection."
Consequence: If the air bag inflator initiator fails to ignite, the air bag will not deploy, increasing the risk of injury.
Remedy: Volvo will notify owners, and dealers will inspect and, if necessary, replace the front seat side air bags, free of charge. The recall began March 31, 2017. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89712. Note: This recall is an expansion of recall 16V-918.
NHTSA campaign record ↗19V327000 · Suspension:Rear
Reported: 2019-04-25 (April 25, 2019) · Model years: 2019
Volvo Car USA LLC (Volvo) is recalling certain 2019 S60 vehicles. The rear suspension toe link flange lock nuts may not have been properly tightened, possibly resulting in a sudden change in vehicle handling.
Consequence: A sudden change in vehicle handling can increase the risk of a crash.
Remedy: Volvo will notify owners, and dealers will inspect the rear toe link flange bolts and lock nuts, replacing them if necessary, free of charge. The recall began June 6, 2019. Owner's my contact Volvo Customer Service at 1-800-458-1552. Volvo's number for this recall is R19938.
NHTSA campaign record ↗20V144000 · Forward Collision Avoidance: Automatic Emergency Braking | Forward Collision Avoidance:Software:Pedestrian/Cyclist/Object/Obstacle/ Recognition
Reported: 2020-03-12 (March 12, 2020) · Model years: 2019, 2020
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.
Consequence: If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.
Remedy: Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.
NHTSA campaign record ↗21V414000 · Electrical System:Wiring:Fuses And Circuit Breakers | Fuel System, Gasoline:Delivery:Fuel Pump
Reported: 2021-06-02 (June 2, 2021) · Model years: 2019, 2020
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
Consequence: Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.
Remedy: Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.
NHTSA campaign record ↗23V780000 · Air Bags:Frontal
Reported: 2023-11-21 (November 21, 2023) · Model years: 2019, 2020, 2021, 2022, 2023, 2024
Volvo Car USA, LLC. (Volvo Car) is recalling certain 2019-2024 S60 vehicles. The passenger air bag may not be secured properly, which can cause the air bag to deploy improperly.
Consequence: An air bag that does not deploy properly in a crash increases the risk of injury.
Remedy: Dealers will inspect and tighten the bolts securing the passenger air bag, as necessary, free of charge. Owner notification letters were mailed January 5, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10254.
NHTSA campaign record ↗25V179000 · Electrical System:Propulsion System:Traction Battery | Electrical System:Software
Reported: 2025-03-24 (March 24, 2025) · Model years: 2020, 2021, 2022
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.
NHTSA campaign record ↗21V682000 · Seat Belts:Rear/Other:Retractor | Seat Belts:Front:Retractor | Seat Belts
Reported: 2021-09-01 (September 1, 2021) · Model years: 2021, 2022
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: An unsecured child restraint system can increase the risk of injury during a crash.
Remedy: Dealers will inspect and replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed October 13, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10111.
NHTSA campaign record ↗22V793000 · Engine And Engine Cooling:Engine:Engine Control Module (Ecu/Ecm)
Reported: 2022-10-20 (October 20, 2022) · Model years: 2022, 2023
Volvo Car USA, LLC (Volvo Car) is recalling certain 2022-2023 S60, V60, S90L, XC60, and XC90 vehicles. An electronic control module (ECM) software error may prevent the combustion engine from starting, causing a loss of drive power.
Consequence: The vehicle may lose drive power as the high voltage battery is depleted, increasing the risk of a crash.
Remedy: Dealers will update the ECM software, free of charge. Owner notification letters are expected to be mailed December 8, 2022. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10198.
NHTSA campaign record ↗23V012000 · Service Brakes, Hydraulic
Reported: 2023-01-19 (January 19, 2023) · Model years: 2023
Volvo Car USA, LLC (Volvo Car) is recalling certain 2023 S60, V60, V60CC, V90CC, XC60, XC90, XC40, and C40 vehicles. A diagnostic error in the Brake Control Module 2 (BCM2) may cause a loss of Antilock Brake System (ABS), Electronic Stability Control (ESC), and traction control.
Consequence: A reduction in brake support functions can increase the risk of a crash.
Remedy: Volvo will release an over-the-air (OTA) BCM2 software update, free of charge. Owner notification letters are expected to be mailed March 15, 2023. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10217.
NHTSA campaign record ↗23V188000 · Electrical System
Reported: 2023-03-22 (March 22, 2023) · Model years: 2023
Volvo Car USA, LLC (Volvo Car) is recalling certain 2023 S60, V60CC, XC60, XC90, XC40, and C40 vehicles. A diagnostic trouble code (DTC) may be falsely detected for the emergency call system (e-call) and display "e-Call Service Required" in the driver information module (DIM).
Consequence: The false warning message could prevent the detection of an actual e-call system failure, which could delay an emergency response during a crash, increasing the risk of injury.
Remedy: Dealers will update the telematics and connectivity antenna module (TCAM) software, free of charge. Owner notification letters are expected to be mailed May 16, 2023. Owners may contact Volvo Car's customer service 1-800-458-1552. Volvo Car's number for this recall is R10225.
NHTSA campaign record ↗25V282000 · Back Over Prevention:Software
Reported: 2025-05-08 (May 8, 2025) · Model years: 2023, 2024, 2025
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2025 S90, V90CC, C40, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40 and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A rearview camera image that does not display reduces the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: The software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10320.
NHTSA campaign record ↗25V908000 · Back Over Prevention:Software
Reported: 2025-12-23 (December 23, 2025) · Model years: 2023, 2024, 2025
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2024 C40BEV, 2022-2025 S90, V90CC, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40, and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence: A rearview camera image that does not display reduces the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: The software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed February 24, 2026. Owners may contact Volvo Car’s customer service at 1-800-458-1552. Volvo Car's number for this recall is R10333. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 16, 2026. This recall replaces previous NHTSA recall number 25V282. Vehicles previously repaired under recall 25V282 will need to have the new remedy performed.
NHTSA campaign record ↗