2017 Winnebago FORZA: complaints, problems and recalls

THE FULL-WALL SLIDEOUT ON MY 2014 WINNEBAGO FORZA 38R OPENED WHILE COACH WAS IN MOTION. I WAS ABLE TO PULL OVER AND STOP WITHOUT INCIDENT. I FOUND THE FRONT OF THE SLIDEOUT FULLY EXTENDED AND THE REAR OUT ABOUT HALF WAY. I USED THE SLIDEOUT SWITCH AND A SERIES OF RETRACT/EXTEND ACTIONS TO BRING IT BACK IN. THE SLIDEOUT ALIGNED ITSELF AND FULLY RETRACTED AS A RESULT OF THESE ACTIONS. THE UNEXPECTED DEPLOYMENT HAPPENED AT 55 MPH ON A TWO-LANE ROAD. THERE WAS A 25 MPH LEFT-TO-RIGHT CROSS WIND WITH SEVERE BUFFETING AS TRUCKS PASSED IN THE O…

Look up ODI 10683559 at NHTSA ↗

WHILE DRIVING ON HIGHWAY, LATCH HOLDING DRIVERS SIDE STORAGE BIN DOOR RELEASED. CAR WAS PASSING AND PRESSURE CHANGES CAUSED DOOR TO FULLY SWING INTO LANE WITH CAR, ABOUT 3 FEET. CAR VEERED AND RECOVERED WITH NO DAMAGE. *DT *DT NOTE THAT DOORS HAVE RELEASED MULTIPLE TIMES WHILE WHILE TRAVELING, BUT THIS WAS THE ONLY TIME IT OPENED INTO ANOTHER LANE. MOTORHOME WAS TAKEN TO THE MANUFACTURER, WHERE THEY ADJUSTED THE LATCHES. DOORS STILL COME OPEN. *TR

Look up ODI 11139743 at NHTSA ↗

OUTSIDE COMPARTMENT DOORS OPEN WHILE IN TRANSIT FOR NO APPARENT REASON DRIVING AT A VARIETY OF SPEEDS STRAIGHT ON HIGHWAYS, WHILE TURNING AND STRAIGHT ROADS IN TOWNS. CONTACTED WINNEBAGO WHO STATED THAT THERE WAS A TSB ON THE ISSUE, HOWEVER, IT TOOK A LONG TIME FOR THE TSB TO REACH THE DEALER WHO ALLEGEDLY HAD NO KNOWLEDGE OF THE TSB IN THE EARLIER TRIPS TO THE DEALER FOR REPAIR. DOOR SEALS WERE REPLACED WITH DIFFERENT SIZE SEALS AND THEN BACK TO ORIGINAL SEALS. DEALER "NOTCHED" LATCHES TO GET THE DOORS TO STAY CLOSED MAKING THE DOORS DIFFICULT…

Look up ODI 11203318 at NHTSA ↗

BAY DOORS OPEN WHILE DRIVING. ONE, I TAPE CLOSED. THIS HAS HAPPENED. MANY TIMES.*DT*DT*JB*AS

Look up ODI 11366162 at NHTSA ↗

WHILE DRIVING ON I-40 BETWEEN WILLIAMS AND FLAGSTAFF, ARIZONA, THE LEVELING JACKS PANEL ACTIVATED AND BEGAN INDICATING THE DEPLOYMENT PROCESS WAS READY TO BEGIN. THE PANEL HAD BEEN SHUT OFF. I HAD DRIVEN FROM LAUGHLIN, NV BEFORE THIS INCIDENT OCCURRED. I STOPPED ON THE SIDE OF THE FREEWAY AND PERFORMED A MANUAL INSPECTION OF THE LEVELING JACKS. THEY DID NOT APPEAR TO HAVE LOWERED. I RESTARTED THE ENGINE, THE PANEL RESPONDED TO THE OFF BUTTON AND I CONTINUED TO MY DESTINATION IN FLAGSTAFF. UPON STOPPING AT MY CAMP SITE, I DEPLOYED THE JA…

Look up ODI 10747055 at NHTSA ↗

MOTOR HOME HAS BED ABOVE DRIVER AND PASSENGER SEATS. THE BED IS RAISED AND LOWERED BY ELECTRIC MOTOR. THE BED ON OUR MH DOES NOT LOCK IN PLACE ON THE PASSENGER SIDE AND SITS ON AN ANGLE LOWERED ON PASSENGER SIDE. THERE IS A SEATBELT TYPE LATCH ON DRIVERS SIDE FOR SAFETY; HOWEVER, WITH BED ON AN ANNIVERSARY GLE, THE BELT CANNOT BE LATCHED. WITH ADDITIONAL STRESS ON DRIVER SIDE MOTOR DRIVE, IT IS DESTINED TO BREAK LOOSE DUE TO BOUNCING MOVEMENT OF VEHICLE. IF THE ATTACHMENTS COME LOOSE, THE BED WILL STRIKE THE DRIVERS HEAD WHILE IN MOTION.

Look up ODI 11166500 at NHTSA ↗

The digital dash instrument panel screen is delaminating.

Look up ODI 11718464 at NHTSA ↗

Delamination of instrument cluster, difficult to read air pressure, engine & transmission temp, engine tach. This is an ongoing problem, seems to be increasing area of distortion. First noticed 9/2024 approximate date.

Look up ODI 11653350 at NHTSA ↗

This complaint is about broken welds on the Superstructure (The framing that runs the length of the Motor Home (RV). It is attached to the chassis frame rails and supports the entire Motor Home including any cargo and equipment like the Fresh Water tanks (100 gallons) Black and Grey waste tanks. It is the backbone of the construction process and supports several thousand pounds and is under incredible stress especially when this 40 foot Motor Home with a dry weight of in in motion. This vehicle has a GVWR of 29,410 lbs. I took the vehicle dow…

Look up ODI 11541664 at NHTSA ↗

TL* THE CONTACT OWNS A 2016 WINNEBAGO FORZA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V277000 (STEERING, SUSPENSION) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

Look up ODI 10898882 at NHTSA ↗

THERE ARE MANY STEERING ISSUES ABOUT THE XCS FREIGHTLINER CHASSIS USED IN THE WINNEBAGO DIESEL PUSHERS. WE HAVE A BRAND NEW WINNEBAGO AND THE STEERING HAS SO MUCH PLAY IN IT. WE HAVE HAD IT TO THE DEALER AND FREIGHTLINER TWICE AND ALL THEY SAY IS IT IS ADJUSTED TO SPECIFICATIONS. THIS RIG IS NOT SAFE TO DERIVE ON THE HIGHWAY. THE AMOUNT OF PLAY IN THE WHEEL MAKES IT DIFFICULT TO KEEP THE MH STRAIGHT ON A ROAD. THIS IS AN ACCIDENT JUST WAITING TO HAPPEN. WE CAN SWAP OUT SOME COMPONENTS AT A STEEP COST, BUT THIS IS A BRAND NEW MH! WE ALS…

Look up ODI 11228952 at NHTSA ↗

The contact owns a 2017 Winnebago Forza built on a 2017 Freightliner XC-S Chassis. The contact stated that the rear brake lights and left turn signals failed to function as intended. No warning lights were illuminated. The RV was taken to a local dealer where it was diagnosed that the power distribution module failed and needed to be replaced. The RV was not repaired due to the VIN not being included in NHTSA Campaign Number: 18V582000 (Exterior Lighting, Electrical System), nor 20V404000 (Electrical System, Exterior Lighting). The manufacturer…

Look up ODI 11611391 at NHTSA ↗

DIGITAL DASH BRIGHTNESS CAN NOT BE LOWERED FAR ENOUGH FOR NIGHTTIME DRIVING

Look up ODI 11355689 at NHTSA ↗

The contact owns a 2017 Winnebago Forza built on a 2017 Freightliner XC-S Chassis. The contact stated that the rear brake lights and left turn signals failed to function as intended. No warning lights were illuminated. The RV was taken to a local dealer where it was diagnosed that the power distribution module failed and needed to be replaced. The RV was not repaired due to the VIN not being included in NHTSA Campaign Number: 18V582000 (Exterior Lighting, Electrical System), nor 20V404000 (Electrical System, Exterior Lighting). The manufacturer…

Look up ODI 11611391 at NHTSA ↗

Dashboard display is de laminating. Freighter says it is not covered because warranty has expired. It is only 5 years old. Others have had the same problem.

Look up ODI 11733321 at NHTSA ↗

The digital dash instrument panel screen is delaminating.

Look up ODI 11718464 at NHTSA ↗

Dashboard display is de laminating. Freighter says it is not covered because warranty has expired. It is only 5 years old. Others have had the same problem.

Look up ODI 11733321 at NHTSA ↗

The contact owns a 2018 Winnebago Forza RV. The contact stated that while driving approximately 65 MPH, the cargo door and the door enclosing the propane tank on the driver's side unexpectedly opened. The contact stated that the failures had occurred several times. The contact stated there was no warning light illuminated. The contact had taken the vehicle to a dealer who was unable to repair the doors properly. The failure had become a recurring failure. The manufacturer was informed of the failure. The contact related the failure to NHTSA Cam…

Look up ODI 11697419 at NHTSA ↗

TL* THE CONTACT OWNS 2019 WINNEBAGO FORZA. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE STORAGE AREA DOOR BECAME UNLATCHED. THE RV WAS TAKEN TO SOUTH HAVEN RV & MARINE LOCATED AT (5485 PEPPER CHASE DR, SOUTHAVEN, MS 3867[phone removed]) WHERE THE RV WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 19V512000 (STRUCTURE) HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1,800.

Look up ODI 11308543 at NHTSA ↗

THERE ARE MANY STEERING ISSUES ABOUT THE XCS FREIGHTLINER CHASSIS USED IN THE WINNEBAGO DIESEL PUSHERS. WE HAVE A BRAND NEW WINNEBAGO AND THE STEERING HAS SO MUCH PLAY IN IT. WE HAVE HAD IT TO THE DEALER AND FREIGHTLINER TWICE AND ALL THEY SAY IS IT IS ADJUSTED TO SPECIFICATIONS. THIS RIG IS NOT SAFE TO DERIVE ON THE HIGHWAY. THE AMOUNT OF PLAY IN THE WHEEL MAKES IT DIFFICULT TO KEEP THE MH STRAIGHT ON A ROAD. THIS IS AN ACCIDENT JUST WAITING TO HAPPEN. WE CAN SWAP OUT SOME COMPONENTS AT A STEEP COST, BUT THIS IS A BRAND NEW MH! WE ALS…

Look up ODI 11228952 at NHTSA ↗