2007 Volkswagen PASSAT WAGON problems and owner complaints

FUEL LEAKING FROM FITTING ON TOP OF TANK NEAR FUEL LEVEL SENDING UNIT.

Look up ODI 11073872 at NHTSA ↗

TL* THE CONTACT OWNS A 2003 VOLKSWAGEN PASSAT WAGON. THE CONTACT STATED THAT AFTER PARKING THE VEHICLE, SHE NOTICED A LEAK FROM THE FUEL SYSTEM. THE LEAK WAS NOTICED ON TWO SEPARATE OCCASIONS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT STATED THAT THE VEHICLE WAS NOT REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 02V026000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

Look up ODI 10510560 at NHTSA ↗

PURCHASED CAR USED. FIRST TIME I FILLED THE GAS TANK STRONG SMELL OF RAW GAS WAS PRESENT DURING THE NEXT SEVERAL MILES OF TRAVEL. WHEN I CAME OUT OF THE STORE FROM PAYING FOR THE SECOND FILL UP THERE WAS A BIG PUDDLE OF RAW FUEL ALL OVER THE GROUND DIRECTLY UNDER THE CAR. I DID SOME RESEARCH & DISCOVERED A MANUFACTURE RECALL FOR THIS VERY ISSUE. FURTHER INVESTIGATION INDICATED THE RECALL HAD ALREADY BEEN REPAIRED BY THE DEALER. AFTER EXPLAINING MY DILEMMA TO THE APPROPRIATE CORPORATE DEPARTMENT I WAS TOLD THERE WAS NOTHING MORE THEY COULD/WOULD…

Look up ODI 10490810 at NHTSA ↗

FIRST OF ALL THE TEKATA AIRBAGS ARE A RECALL. THE FUEL PUMP MODULE. IT ALL STARTED WOH PHEN THE FUEL PUMP MODULES FAILED AND THE CAR WOULD TURN ON BUT TURN RIGHT OFF AND I WAS TOLD IT WAS THE FUEL PUMP MODULES WHEN I HAD IT DIAGNOSED. NOW IT LEAKS OUT A LOT OF GAS IN FOUR DIFFERENT SPOTS UNDER THE CAR ON PASSENGERS SIDE. WHEN WE PARKED THE CAR WE STARTED NOTICING THIS 4 MONTHS AGO.

Look up ODI 11023881 at NHTSA ↗

SUMMARY ON CERTAIN VEHICLES, THERE COULD BE AN INTERRUPTION IN ELECTRICAL POWER TO THE FUEL PUMP CONTROL MODULE. THIS COULD RESULT IN THE FUEL PUMP RUNNING CONTINUOUSLY, RESULTING IN A DRAINED BATTERY AND/OR A NO START CONDITION, OR CAUSE A LOSS OF MOTIVE POWER WHILE THE VEHICLE IS IN MOTION, WHICH COULD INCREASE THE RISK OF A CRASH CAUSING INJURY AND/OR DAMAGE TO PROPERTY. RECALL STATUS RECALL INCOMPLETE. REMEDY NOT YET AVAILABLE REMEDY REPLACE THE FUEL PUMP CONTROL MODULE AND RELOCATE IT WITHIN THE VEHICLE. SAFETY RISK DESCRPITION A LO…

Look up ODI 11041550 at NHTSA ↗

THE VEHICLE STOPPED WHILE IN MOTION ON HIGHWAY. THE DEALER REPLACED FUEL PUMP BUT DIDN'T "RELOCATE" IT IN THE VEHICLE AS SUGGESTED ON YOUR WEBSITE. I PAID $988. MY QUESTION IS: WHO SHOULD PAY THE "REMEDY" COST?

Look up ODI 11062205 at NHTSA ↗

THERE WAS AN INTERRUPTION IN ELECTRICAL POWER FROM THE FUEL PUMP CONTROL MODULE. THIS RESULTED IN THE FUEL PUMP RUNNING CONTINUOUSLY, RESULTING IN A DRAINED BATTERY AND NO START CONDITION, OR CAUSE A LOSS OF MOTIVE POWER WHILE THE VEHICLE WAS IDLE AT TRAFFIC LIGHTS. TOOK THE CAR TO VW GARAGE WHO WERE AWARE OF THE PROBLEM SAID THERE WOULD BE A SAFETY RECALL SOON, BUT I SHOULD PAY FOR REPAIR AND CLAIM MONEY BACK ONCE RECALL WAS ACTIVE, WAS TOLD THIS WOULD BE EARLY PART OF 2018. STILL NO RECALL AND OVER $400 OUT OF POCKET. CAR STALLED AND CUT OUT …

Look up ODI 11097100 at NHTSA ↗

I WAS DRIVING UP SOMEWHAT OF A HILL AND HAD TO SLOW DOWN DUE TO A BIT OF TRAFFIC FLOW. I HAD REALIZED I WAS A LITTLE CLOSER THAN I THOUGHT SO I BRAKED A LITTLE HARDER THAN USUAL. MY BRAKES WERE GRABBING ON TIGHTLY TO THE GROUND LIKE THEY SHOULD BUT THEN SEEMED TO HAVE GIVEN OUT AT THE LAST COUPLE SECONDS. MY CAR HIT THE CAR IN FRONT OF ME, RESULTING IN BOTH MY FRONT AIRBAGS GOING OFF. THE AIRBAG ON THE PASSENGER SIDE AND SWUNG OUT AND HIT MY RIGHT HAND, RESULTING IN SOME MINOR BURNS AND SCRAPES. I THEN STARTED GOING BACKWARDS AFTER THE CAR IN F…

Look up ODI 10563783 at NHTSA ↗

AIRBAG WARNING LIGHTS CAME ON WITH A STATEMENT ABOUT FAULTY AIRBAG ... EPC WARNING LIGHTS CAME ON FIRST WHEN VEHICLE WAS IN MOTION. VEHCLE WAS STOPPED. ON RE-START, AIR BAG WARNING LIGHTS CAME ON. VEHICLE WAS IDDLING AND STATIONARY.

Look up ODI 10971433 at NHTSA ↗

TL* TAKATA RECALL. THE CONTACT OWNS A 2007 VOLKSWAGEN PASSAT WAGON. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V079000 (AIR BAGS) FOR THE FRONTAL DRIVER AIR BAG INFLATOR. THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED THE LOCAL DEALER (DONALDSONS VOLKSWAGEN LOCATED ON 5700 SUNRISE HWY, SAYVILLE, NY, 11782) AND WAS INFORMED THAT PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND INFORMED THE…

Look up ODI 11002367 at NHTSA ↗

MY VEHICLE WAS INVOLVED IN THE AIRBAG RECALL. AFTER IT WAS REPAIRED, THE CLOCKSPRING FAILED AND THE "AIRBAG ERROR" LIGHT CAME ON. THIS VEHICLE ISN'T PART OF THE EARLIER CLOCKSPRING RECALL, BUT IT SHOULD BE.

Look up ODI 11083491 at NHTSA ↗

ROLLED INTO VEHICLE IN FRONT. NO DAMAGE TO EITHER VEHICLE. CAR BURST IN TO FLAMES. TOTAL LOSS. *TR

Look up ODI 10593014 at NHTSA ↗

MY FRONT DRIVER SEAT WARMER WAS TURNED ON LOW. I COULD FEEL THE SEAT GETTING WARMER AND CHECKED TO BE SURE THE SETTING WAS NOT ON HIGH WHICH IT WASN'T. I THOUGHT MAYBE I WAS BEING SENSITIVE AND STUCK MY MITTEN UNDER MY THIGH. I THEN NOTICED A FUNNY SMELL AND SUDDENLY THINGS GOT VERY HOT AND STARTED TO BURN MY LEG AS I WAS DRIVING. I LOOKED DOWN AND ACTUALLY STARTED TO SEE SMOKE. I WAS NOT ABLE TO JUST PULL OVER BUT QUICKLY TURNED THE SEAT OFF. I PULLED OUT MY MITTEN AND FLEECE WAS ACTUALLY MELTED. I WAS A BLOCK OR TWO FROM WORK AND TRIED TO …

Look up ODI 10836594 at NHTSA ↗

HAD TO REPLACE THE COMFORT CONTROL MODULE ALONG WITH UNTOLD AMOUNT OF WIRES DUE TO WATER DAMAGE. AFTER BEING PARKED AND TURNED OFF THE WINDOWS ROLL. DOWN THE ALARM IS DISABLED, THE DOORS UNLOCK. WHILE DRIVING LIGHTS GO. ON AND OFF DOORS LOCK AND UNLOCK EMERGENCY FLASHERS GO OFF AND ALARM WILL GO OFF. CAN'T UNLOCK CAR WITHOUT SETTING ALARM OFF.

Look up ODI 11184655 at NHTSA ↗

FIRST OF ALL THE TEKATA AIRBAGS ARE A RECALL. THE FUEL PUMP MODULE. IT ALL STARTED WOH PHEN THE FUEL PUMP MODULES FAILED AND THE CAR WOULD TURN ON BUT TURN RIGHT OFF AND I WAS TOLD IT WAS THE FUEL PUMP MODULES WHEN I HAD IT DIAGNOSED. NOW IT LEAKS OUT A LOT OF GAS IN FOUR DIFFERENT SPOTS UNDER THE CAR ON PASSENGERS SIDE. WHEN WE PARKED THE CAR WE STARTED NOTICING THIS 4 MONTHS AGO.

Look up ODI 11023881 at NHTSA ↗

SUMMARY ON CERTAIN VEHICLES, THERE COULD BE AN INTERRUPTION IN ELECTRICAL POWER TO THE FUEL PUMP CONTROL MODULE. THIS COULD RESULT IN THE FUEL PUMP RUNNING CONTINUOUSLY, RESULTING IN A DRAINED BATTERY AND/OR A NO START CONDITION, OR CAUSE A LOSS OF MOTIVE POWER WHILE THE VEHICLE IS IN MOTION, WHICH COULD INCREASE THE RISK OF A CRASH CAUSING INJURY AND/OR DAMAGE TO PROPERTY. RECALL STATUS RECALL INCOMPLETE. REMEDY NOT YET AVAILABLE REMEDY REPLACE THE FUEL PUMP CONTROL MODULE AND RELOCATE IT WITHIN THE VEHICLE. SAFETY RISK DESCRPITION A LO…

Look up ODI 11041550 at NHTSA ↗

CAR STOPPED ON A HIGHWAY WHILE IN MOTION. WENT TO THE VW DEALER. THEY FOUND "FAULTS FOR FUEL MODULE, AND FUEL PUMP UNIT." THEY REMOVED AND INSTALLED FUEL PUMP AND TUBE BUT DIDN'T TELL ME IT WAS A RECALLED ITEM/PART. I PAID THE FULL AMOUNT OUT OF MY POCKET: $988.57

Look up ODI 11071593 at NHTSA ↗

MY VEHICLE WAS INVOLVED IN THE AIRBAG RECALL. AFTER IT WAS REPAIRED, THE CLOCKSPRING FAILED AND THE "AIRBAG ERROR" LIGHT CAME ON. THIS VEHICLE ISN'T PART OF THE EARLIER CLOCKSPRING RECALL, BUT IT SHOULD BE.

Look up ODI 11083491 at NHTSA ↗

TL* THE CONTACT OWNS A 2001 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE EMISSIONS WARNING INDICATOR ILLUMINATED INTERMITTENTLY ON THE INSTRUMENT PANEL. THE CONTACT APPROACHED A TRAFFIC STOP AND A STRONG ODOR OF BURNING OIL EMITTED FROM INSIDE OF THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED OIL LEAKING ONTO THE CATALYTIC CONVERTER. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 154,000. UPDATED 04/30/13*LJ THE CONSUMER STATED THE EMISSION WORKSHOP LIGHT I…

Look up ODI 10502621 at NHTSA ↗

ENGINE FAILURE, CAR WAS DRIVING PERFECT NO PROBLEMS. ALL OF A SUDDEN IT STARTS VIBRATING AND SHAKING OUT OF CONTROL. CALLED MY MECHANIC HE TOLD ME TO BRING IT BY, I STARTED ON MY WAY TO DRIVE TO THE SHOP SO HE COULD TAKE A LOOK. CAR DIED 1 MILE FROM SHOP WHILE I WAS DRIVING IN TRAFFIC. I WAS GOING 45MPH WGEN IT FAILED, I HAD TO GET OUT THE CAR PUSH IT OUT OF TRAFFIC BY MYSELF. A VW PASSAT WAGON! HEAVY? YES VERY MUCH SO. GOT IT TOWED MY MECHANIC LOOKED AT IT AND SAID IT WASNT GETTIN ENOUGH OIL.

Look up ODI 10957389 at NHTSA ↗

2008 VOLKSWAGEN PASSAT WAGON TIMING CHAIN BROKE WHILE DRIVING ON INTERSTATE CAUSING ENGINE FAILURE, 160K MILES. VERY SCARY!!!!!!

Look up ODI 11221154 at NHTSA ↗

SINCE THE SUMMER OF 2017 I HAVE BEEN HAVING PROBLEMS WITH MY PASSAT STALLING, AND OR LOOSING POOWER WHEN I AM DRIVING, LAST SEPTEMBER 2017 I WAS TOLD THAT A RECALL (20AE) WAS COMING OUT THAT WAS RELATED TO MY FAILURES. AROUND OCTOBER 15, 2017 I FOUND OUT THAT THE RECALL WAS ISSUED. SINCE THEN I HAVE BEEN TOLD BY THE LOCAL VOLKSWAGON GARAGE THAT PARTS FOR THE RECALL ARE NOT AVAILABLE. MY CASE# FROM VOLKSWAGON GROUP OF AMERICA IS #519607. AT ONE POINT I WAS TOLD BY VOLKSWAGON GROUP OF AMERICA THAT I SHOULD GET IN TOUCH WITH MY LOCAL DEALER (V…

Look up ODI 11101057 at NHTSA ↗

TIMING CHAIN BROKE AT 69,000 MILES. OIL CHANGES WERE KEPT UP WITH CONSISTENTLY WITH CAR. ENGINE NOW HAS TO BE REPLACED IN ORDER FOR CAR TO DRIVE. VEHICLE WAS STATIONARY WHEN IT STOPPED WORKING.

Look up ODI 11035392 at NHTSA ↗

TL* THE CONTACT OWNS A 2002 VOLKSWAGEN PASSAT WAGON. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. THE EMERGENCY BRAKE WAS ENGAGED IN ORDER TO SLOW DOWN; HOWEVER, THE VEHICLE THEN CRASHED INTO THE REAR OF ANOTHER VEHICLE. THERE WERE NO PERSONAL INJURIES. A POLICE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE NO REPAIRS WERE PERFORMED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 151,000.

Look up ODI 10509823 at NHTSA ↗

ROLLED INTO VEHICLE IN FRONT. NO DAMAGE TO EITHER VEHICLE. CAR BURST IN TO FLAMES. TOTAL LOSS. *TR

Look up ODI 10593014 at NHTSA ↗

I WAS DRIVING UP SOMEWHAT OF A HILL AND HAD TO SLOW DOWN DUE TO A BIT OF TRAFFIC FLOW. I HAD REALIZED I WAS A LITTLE CLOSER THAN I THOUGHT SO I BRAKED A LITTLE HARDER THAN USUAL. MY BRAKES WERE GRABBING ON TIGHTLY TO THE GROUND LIKE THEY SHOULD BUT THEN SEEMED TO HAVE GIVEN OUT AT THE LAST COUPLE SECONDS. MY CAR HIT THE CAR IN FRONT OF ME, RESULTING IN BOTH MY FRONT AIRBAGS GOING OFF. THE AIRBAG ON THE PASSENGER SIDE AND SWUNG OUT AND HIT MY RIGHT HAND, RESULTING IN SOME MINOR BURNS AND SCRAPES. I THEN STARTED GOING BACKWARDS AFTER THE CAR IN F…

Look up ODI 10563783 at NHTSA ↗

WHILE DRIVING 2009 VW PASSAT WAGON ON I-495 SOUTH IN HAVERHILL, MA, AT AROUND 5 PM, SMOKE SUDDENLY BEGAN BILLOWING OUT OF THE VENTS. DRIVER WAS ABLE TO PULL ONTO THE SHOULDER SAFELY (NEAR EXIT 48/ MILE MARKER 105.6) AND EXIT THE CAR, WHICH WAS ENGULFED IN FLAMES WITHIN A MINUTE. NO PASSENGERS, NO INJURIES, NO OTHER CARS WERE DAMAGED. UP TO THIS POINT, THE CAR HAD BEEN FUNCTIONING NORMALLY. NO OVERHEATING, NO LEAKING, NO WARNING LIGHTS, NO OTHER INDICATION OF IMPENDING FIRE. MASSACHUSETTS STATE POLICE FROM THE ANDOVER BARRACKS RESPONDED [pho…

Look up ODI 11109833 at NHTSA ↗

AIRBAG WARNING LIGHTS CAME ON WITH A STATEMENT ABOUT FAULTY AIRBAG ... EPC WARNING LIGHTS CAME ON FIRST WHEN VEHICLE WAS IN MOTION. VEHCLE WAS STOPPED. ON RE-START, AIR BAG WARNING LIGHTS CAME ON. VEHICLE WAS IDDLING AND STATIONARY.

Look up ODI 10971433 at NHTSA ↗

FUEL PUMP CONTROL MODULE I HAVE A SPECIAL NEEDS CHILD THAT REQUIRES ME TO BE IN MY VEHICLE 85% OF THE TIME I HAVE LOVED MY VW PASSAT AND ENJOYED DRIVING IT UP TILL ABOUT 1.5 YEARS ITS BEEN ONE FIX AFTER ANOTHER SOME MAJOR SOME NOT IVE HAD CHECK ENGINE LIGHT PROBLEMS, ADDING OIL IN BETWEEN CHANGES TIRE ROD ETC THIS ISSUE IM HAVING AT THIS TIME IS ON RECALL LIST ( FUEL PUMP CONTROL) I HAVE BEEN PUT IN SEVERAL UNSAFE MOMENTS LEFT STRANDED. I HAVE BEEN ON HWY MY CAR STALLS OUT CAUSE DRIVING BACK AN FOURTH TO DUKE HOSPITAL IM ON HWY ALOT, I AM ST…

Look up ODI 11064333 at NHTSA ↗

HAD TO REPLACE THE COMFORT CONTROL MODULE ALONG WITH UNTOLD AMOUNT OF WIRES DUE TO WATER DAMAGE. AFTER BEING PARKED AND TURNED OFF THE WINDOWS ROLL. DOWN THE ALARM IS DISABLED, THE DOORS UNLOCK. WHILE DRIVING LIGHTS GO. ON AND OFF DOORS LOCK AND UNLOCK EMERGENCY FLASHERS GO OFF AND ALARM WILL GO OFF. CAN'T UNLOCK CAR WITHOUT SETTING ALARM OFF.

Look up ODI 11184655 at NHTSA ↗

PLASTIC HEADLIGHT COVERS ARE KNOWN TO DETERIORATE DUE TO SUNLIGHT. I AM TOLD I HAVE LOST 30% OF MY HEADLIGHTS' CAPACITY TO ILLUMINATE THE ROAD. VW WANTS MORE THAN $900 TO REPLACE THEM, CLAIMING THEY ARE PERMANENTLY ATTACHED TO THE ENTIRE HEADLIGHT ASSEMBLIES.

Look up ODI 11055954 at NHTSA ↗