Winnebago SIGHTSEER recalls by model year

Reported: 2010-10-26 (October 26, 2010) · Model years: 1996, 1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011

WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.

Reported: 2003-02-21 (February 21, 2003) · Model years: 2000, 2001, 2002, 2003

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105,"HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY THE STANDARD.

Consequence: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE SYSTEM WARNING INDICATOR.

Remedy: DEALERS WILL REPAIR THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 25, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-3535.

Reported: 2003-10-16 (October 16, 2003) · Model years: 2001, 2002, 2003, 2004

ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR WINNEBAGO AT 641-585-3535.

Reported: 2009-05-28 (May 28, 2009) · Model years: 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009

WINNEBAGO IS RECALLING VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Consequence: THE DRIVER WOULD NORMALLY DETECT THE BRAKE DRAG BUT IF UNDETECTED THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE WORKHORSE IS HANDLING THE REMEDY FOR THIS CAMPAIGN PLEASE SEE 09V-110. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731 OR WINNEBAGO AT 1-641-585-3535.

Reported: 2003-07-08 (July 8, 2003) · Model years: 2002, 2003, 2004

ON CERTAIN MOTOR HOMES, WHEN THE COOKING RANGE AND FURNACE ARE OPERATING AT THE SAME TIME, THE FLAME ON THE COOKING RANGE COULD BE FORCED DOWNWARD OVER THE BURNER OR FLAME OUTAGE COULD OCCUR. THIS CONDITION IS DUE TO THE LOCATION OF THE FURNACE AND COOKING RANGE WHEREBY THE FURNACE MAY DRAW AIR IN FROM ABOVE THE RANGE BURNERS AND CAUSE A DOWNDRAFT.

Consequence: SHOULD THIS OCCUR, THE FLAME MAY GO OUT, AND THE LIQUID PROPANE (LP) GAS WILL CONTINUE TO FLOW. THIS IS A HAZARDOUS SITUATION THAT COULD RESULT IN AN EXPLOSION OR FIRE.

Remedy: DEALERS WILL INSTALL AN AIR RESTRICTOR PANEL UNDER THE RANGE. OWNER NOTIFICATION BEGAN JULY 10, 2003. OWNERS SHOULD CONTACT WINNEBAGO AT 1-641-585-6939.

Reported: 2003-02-20 (February 20, 2003) · Model years: 2003

ON CERTAIN MODEL D30B MOTOR HOMES BUILT ON A FORD CHASSIS, A PLATE, WHICH IS USED TO SUPPORT THE SPARE TIRE, WAS INADVERTENTLY LEFT OFF A NUMBER OF THESE MOTOR HOMES.

Consequence: WITHOUT THIS ADDITIONAL SUPPORT, THE SPARE TIRE COULD FALL OFF THE VEHICLE RESULTING IN PROPERTY DAMAGE AND POSSIBLY PERSONAL INJURY.

Remedy: DEALERS WILL INSPECT THE SPARE TIRE MOUNT AND, IF NECESSARY, INSTALL A NEW SUPPORT PLATE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING MARCH 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-6939.

Reported: 2004-07-19 (July 19, 2004) · Model years: 2003

ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, MODELS MR1031WB, MR1032BB, MR1033SB, MR1351WB, AND MR1352BB, THE MICROWAVES WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 1-800-932-3837 OR WINNEBAGO AT 1-641-585-3535.

Reported: 2004-12-22 (December 22, 2004) · Model years: 2003, 2004, 2005

ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS, THERE MAY NOT BE SUFFICIENT CLEARANCE IN THE AREA WHERE THE FUEL LINE CROSSES THE FRAME CROSS MEMBER.

Consequence: WITHOUT CLEARANCE, A CONDITION COULD DEVELOP WHERE THE CROSS MEMBER MAY WEAR INTO THE FUEL LINE AND A FUEL LEAK MAY DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPAIR THESE MOTOR HOMES BY PROVIDING CLEARANCE BETWEEN THE FUEL LINE AND FRAME CROSS MEMBER. THE FUEL LINE WILL BE INSPECTED AND, IF NECESSARY, REPLACED. THE RECALL BEGAN JANUARY 7, 2005. OWNERS SHOULD CONTACT WINNEBAGO AT 1-800-537-1885.

Reported: 2004-12-18 (December 18, 2004) · Model years: 2004, 2005

CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

Consequence: THE SEAT BELT BUCKLE MAY UNLATCH IN THE EVENT OF A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY TO THE SEAT OCCUPANT.

Remedy: DEALERS WILL REPLACE THE BUCKLES. THE RECALL BEGAN ON NOVEMBER 12, 2004. OWNERS SHOULD CONTACT AMSAFE AT 1-574-266-8330 OR WINNEBAGO AT 1-800-537-1885.

Reported: 2010-10-05 (October 5, 2010) · Model years: 2005, 2006, 2007, 2008, 2009

WINNEBAGO IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2009 WINNEBAGO SIGHTSEER AND ITASCA SUNOVA MOTOR HOMES BECAUSE THE DINETTE AREA SEAT BELT RESTRAINTS ON THOSE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." IN A COLLISION, THE GENERATED CRASH FORCES CAN CAUSE THE RESTRAINT'S ATTACHMENT TO TEAR AND ALLOW THE ANCHOR TO SEPARATE FROM THE BODY OF THE VEHICLE.

Consequence: IF THE RESTRAINT SEPARATES FROM THE VEHICLE DURING A CRASH, THE BELT WILL NOT PROPERLY RESTRAIN THE SEAT OCCUPANT, INCREASING THE RISK OF INJURY OR DEATH TO THE OCCUPANT.

Remedy: WINNEBAGO WILL NOTIFY OWNERS A DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 10, 2010. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.

Reported: 2005-11-09 (November 9, 2005) · Model years: 2006

ON CERTAIN MOTOR HOMES WITH THE OPTIONAL GALLEY UPGRADE PACKAGE, KNIVES STORED IN THE GALLEY KNIFE HOLDER MAY INTERFERE WITH THE PROPANE GAS LINE TO THE STOVE.

Consequence: THE KNIVES COULD DAMAGE THE PROPANE GAS LINE ALLOWING PROPANE GAS TO ESCAPE, WHICH HAS THE POTENTIAL TO IGNITE, RESULTING IN PERSONAL INJURY OR VEHICLE PROPERTY DAMAGE.

Remedy: DEALERS WILL PROPERLY ROUTE THE PROPANE GAS LINE AND INSTALL A KNIFE SHIELD. THE RECALL BEGAN ON NOVEMBER 11, 2005. OWNERS MAY CONTACT WINNEBAGO AT 641-585-6939.

Reported: 2005-12-28 (December 28, 2005) · Model years: 2006

ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC STEPS, THE STEPS MAY HAVE BEEN MANUFACTURED WITH DEFECTIVE STEP CONTROL UNITS.

Consequence: THE DEFECTIVE CONTROL UNITS COULD DEVELOP AN ELECTRICAL SHORT ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE, POSSIBLY RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.

Remedy: DEALERS WILL INSPECT THE KWIKEE STEP AND REPLACE THE STEP CONTROL UNIT, IF NECESSARY, FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 23, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.

Reported: 2006-05-16 (May 16, 2006) · Model years: 2006

ON CERTAIN MOTOR HOMES, THE FLAME ON THE COOKING RANGE MAY BE FORCED DOWNWARD OVER THE BURNER OR FLAME OUTAGE MAY OCCUR WHEN THE COOKING RANGE AND FURNACE ARE OPERATED AT THE SAME TIME. THIS CONDITION IS DUE TO THE POSSIBILITY OF A MISSING CABINET PANEL THAT ISOLATES THE FURNACE RETURN AIR.

Consequence: IF THE FURNACE IS OPERATED AT THE SAME TIME AS THE STOVE AND THE CABINET PANEL IS MISSING, THE STOVE FLAME MAY GO OUT AND THE PROPANE GAS WILL CONTINUE TO FLOW, WHICH HAS THE POTENTIAL TO IGNITE RESULTING IN PERSONAL INJURY OR VEHICLE AND PROPERTY DAMAGE.

Remedy: DEALERS WILL INSPECT THE CABINET ASSEMBLY FOR A CABINET PANEL AND INSTALL ONE IF NECESSARY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON JUNE 2, 2006. OWNERS MAY CONTACT WINNEBAGO AT 641-585-6939.

Reported: 2006-07-05 (July 5, 2006) · Model years: 2006, 2007

CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE STEERING COULD BECOME LOOSE AT THE STEERING BOX DURING TIGHT STEERING MANEUVERS.

Consequence: THIS STEERING CONDITION COULD RESULT IN A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.

Remedy: WORKHORSE IS CONDUCTING THIS RECALL (PLEASE SEE 06V148000) AND WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFT. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6883 OR WINNEBAGO AT 1-641-585-3535.

Reported: 2008-03-28 (March 28, 2008) · Model years: 2006, 2007

WINNEBAGO IS RECALLING 31 MY 2006-2008 JOURNEY, VOYAGE, MY 2006-2007 SIGHTSEER, MY 2006 ADVENTURER, MINNIE WINNIE, MY 2007 ACCESS, TOUR, VECTRA, ITASCA CAMBRIA, AND MY 2007-2008 ITASCA HORIZON MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: WINNEBAGO IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). THE RECALL BEGAN ON APRIL 9, 2008. OWNERS MAY CONTACT RICON AT 1-818-267-3000.

Reported: 2008-08-12 (August 12, 2008) · Model years: 2006, 2007, 2008

WINNEBAGO IS RECALLING 31 MY 2006-2008 ITASCA CAMBRIA, HORIZON, WINNEBAGO ACCESS, ADVENTURER, JOURNEY, MINNIE WINNIE, SIGNTSEER, TOUR, VECTRA, AND VOYAGE MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Remedy: WINNEBAGO IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-800-322-2884 OR WINNEBAGO AT 1-641-585-3535.

Reported: 2008-10-29 (October 29, 2008) · Model years: 2006, 2007, 2008, 2009

WINNEBAGO IS RECALLING 717 MY 2006-2009 SIGHTSEER AND VISTA, ITASCA SUNOVA AND SUNSTAR MOTOR HOMES BUILT ON WORKHORSE CHASSIS. THE CASTLE NUT THAT RETAINS THE STEERING DRAG LINK TO THE PITMAN ARM MAY HAVE BEEN IMPROPERLY TORQUED DURING ASSEMBLY. THE IMPROPER TORQUE MAY HAVE DAMAGED THE CASTLE NUT AND COMPROMISED THE INTEGRITY OF THE CONNECTION.

Consequence: IF THE DRAG LINK WERE TO SEPARATE FROM THE PITMAN ARM, THE DRIVER WOULD NOT HAVE DIRECTIONAL CONTROL OF THE VEHICLE POSSIBLY CAUSING A CRASH.

Remedy: WINNEBAGO IS WORKING WITH WORKHORSE TO REPLACE AND PROPERLY TIGHTEN THE CASTLE NUT THAT RETAINS THE STEERING DRAG LINK TO THE PITMAN ARM (PLEASE SEE 08V442). OWNERS MAY CONTACT WORKHORSE AT 1-877-946-7731 OR WINNEBAGO AT 1-641-585-3535.

Reported: 2007-05-07 (May 7, 2007) · Model years: 2007

ON CERTAIN MOTOR HOMES, IF THE BATTERY BOOST SWITCH IS ENGAGED WHILE THE ENGINE IS OPERATING, THE ENGINE MAY SHUT DOWN.

Consequence: THIS COULD CAUSE LOSS OF DRIVER CONTROL INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A DIODE WIRE ASSEMBLY ON THE AUXILIARY START SOLENOID. THE RECALL BEGAN ON MAY 11, 2007. OWNERS CAN CONTACT WINNEBAGO AT 1-800-537-1885.

Reported: 2009-09-01 (September 1, 2009) · Model years: 2007, 2008, 2009, 2010

WINNEBAGO IS RECALLING MODEL YEAR 2007-2008 ACCESS, ASPECT, SIGHTEER AND VISTA, MODEL YEAR 2007-2008 ITASCA IMPULSE, CAMBRIA, SUNOVA, AND SUNSTAR, MODEL YEAR 2009-2010 WINNEBAGO ACCESS, SIGHTSEER AND VISTA, MODEL YEAR 2009-2010 ITASCA IMPULSE, SUNOVA, AND SUNSTAR MOTOR HOMES. THESE MOTOR HOMES MAY HAVE A MISSING STOVE PARTITION THAT ISOLATES THE FURNACE AIR.

Consequence: IF THE FURNACE IS OPERATED AT THE SAME TIME AS THE STOVE AND PARTITION IS MISSING, THE STOVE FLAME MAY GO OUT AND THE PROPANE GAS WILL CONTINUE TO FLOW, WHICH HAS THE POTENTIAL TO IGNITE RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.

Remedy: DEALERS WILL CORRECT THIS SITUATION BY INSTALLING A STOVE PARTITION THAT ISOLATES THE STOVE FROM THE FURNACE RETURN AIR AT NO CHARGE TO THE OWNER. THE RECALL BEGAN ON SEPTEMBER 30, 2009. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.

Reported: 2008-12-19 (December 19, 2008) · Model years: 2009

WINNEBAGO IS RECALLING 36 MY 2009 VISTA, SIGHTSEER, AND ITASCA SUNSTAR AND SUNOVA MOTOR HOMES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF PART 567, 'CERTIFICATION.' . THESE VEHICLES WERE PRODUCED WITH A VEHICLE CERTIFICATION LABEL THAT STATES LOAD RANGE 'G' TIRES WHEN IN FACT THE VEHICLES ARE EQUIPPED WITH LOAD RANGE 'F' TIRES.

Consequence: THE PURPOSE OF THIS PART IS TO SPECIFY THE CONTENT AND LOCATION OF, AND OTHER REQUIREMENTS FOR, THE CERTIFICATION LABEL TO BE AFFIXED TO MOTOR VEHICLES TO ADDRESS CERTIFICATION-RELATED DUTIES AND LIABILITIES, AND TO PROVIDE THE CONSUMER WITH INFORMATION TO ASSIST HIM OR HER IN DETERMINING WHICH OF THE FEDERAL MOTOR VEHICLE SAFETY STANDARDS ARE APPLICABLE TO THE VEHICLE.

Remedy: WINNEBAGO WILL PROVIDE CORRECT FEDERAL CERTIFICATION LABELS AS WELL AS INSTALLATION INSTRUCTIONS TO THE MOTOR HOME OWNERS. IF AN OWNER DESIRES, THEY CAN HAVE THEIR DEALER REPLACE THE TAGS FOR THEM. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT JANUARY 2, 2009. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-6939.

Reported: 2012-02-16 (February 16, 2012) · Model years: 2011, 2012, 2013

WINNEBAGO IS RECALLING CERTAIN MODEL YEAR 2011-2012 WINNEBAGO AND ITASCA MOTOR HOMES BUILT ON A FORD F-53 CHASSIS. THE ‘PRNDL’ CABLE MAY BREAK AT THE ATTACHMENT TO THE TRANSMISSION CONTROL SELECTOR ARM ASSEMBLY MOUNTED ON THE STEERING COLUMN. IF THE CABLE BREAKS, THE TRANSMISSION GEAR INDICATOR IN THE ‘PRNDL’ DISPLAY IN THE INSTRUMENT PANEL WILL REMAIN IN THE FIRST GEAR POSITION REGARDLESS OF THE GEAR SELECTED.

Consequence: AN INCORRECT GEAR INDICATION IN THE INSTRUMENT PANEL MAY PREVENT THE DRIVER FROM KNOWING IF THEY ARE IN PARK OR REVERSE, INCREASING THE RISK OF A CRASH.

Remedy: WINNEBAGO WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE TRANSMISSION SELECTOR ARM ASSEMBLY AND THE ‘PRNDL’ CABLE ASSEMBLY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 2, 2012. OWNERS MAY CONTACT WINNEBAGO INDUSTRIES OWNER RELATIONS AT 1-641-585-6939.

Reported: 2012-08-08 (August 8, 2012) · Model years: 2012

Winnebago is recalling certain model year 2012-2013 Winnebago and Itasca motor homes. A cutting machine may have scored the copper propane tubing resulting in unknown long-term reliability.

Consequence: If the copper tubing fails, propane can escape leading to a fire or explosion which can result in property damage, personal injury, or death.

Remedy: Winnebago will notify owners, and dealers will replace the copper tubing, free of charge. The recall began on September 6, 2012. Owners may contact Winnebago Industries Owner Relations at 1-641-585-6939.

Reported: 2013-04-24 (April 24, 2013) · Model years: 2012, 2013, 2014

Winnebago Industries is recalling certain model year 2012-2014 Minnie Winnie, Aspect, Sightseer, Adventurer, and Journey motorhomes; and model year 2012-2014 Itasca Spirit, Cambria, Sunova, Suncruiser, and Meridian motorhomes. The affected vehicles were manufactured January 10, 2012, through April 5, 2013 and may be missing a range enclosure.

Consequence: A missing range enclosure may allow the gas range flame to be extinguished due to air flow. In such a case, propane gas will continue to flow without a flame. If propane continues to flow, in the presence of an ignition source, it may suddenly combust resulting in a fire and/or personal injury.

Remedy: Winnebago notify owners and dealers will install a range enclosure, free of charge. The safety recall began on May 20, 2013. Owners may contact Winnebago at 1-641-585-3535. Winnebago's recall campaign number is 128.

Reported: 2013-04-26 (April 26, 2013) · Model years: 2013, 2014

Winnebago Industries, Inc. (Winnebago) is recalling certain model year 2013-2014 Winnebago Access, Aspect, Sightseer, Vista, Adventurer, Forza and Itasca Impulse, Cambria, Sunova, Sunstar, Suncruiser motorhomes manufactured February 20, 2013, through April 25, 2013. If the awning installation sequence was not completely followed, the awning motor may unknowningly become damaged. A damaged motor may lead to an unfurling of the awning.

Consequence: If motor damage occurs, it is possible that the awning can unfurl unexpectedly, either while the motorhome is at rest or while in transit, increasing the risk of personal injury or a vehicle crash.

Remedy: Winnebago will notify owners and Dometic staff will replace the affected motors with a design that is not subject to an out-of-sequence installation error. The recall began on July 17, 2013. Owners may contact Winnebago at 1-800-537-1885 or Dometic at 1-888-447-0003 for more information. Owners are being instructed not to drive their vehicle until repairs can be performed.

Reported: 2017-12-07 (December 7, 2017) · Model years: 2013, 2014, 2015, 2016, 2017, 2018

Winnebago Industries, Inc. (Winnebago) is recalling certain 2013-2018 Winnebago Era, Travato, Minnie Winnie, Fuse, View, Trend, Aspect, Brave, Vista, Sightseer, Adventurer, Forza, Journey, Tour, Revel, Paseo, Chalet, Access, and Intent motorhomes and Commercial vehicles, and 2013-2018 Itasca Spirit, Navion, Cambria, Tribute, Sunstar, Sunova, Suncruiser, Solei, Meridian, Elipse, Horizon, Reyo, and Via motorhomes. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' fire extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Winnebago will notify owners, instructing them to contact Kidde for replacement or aftermarket fire extinguishers, free of charge. The recall began on January 19, 2018. Owners may contact Winnebago customer service at 1-641-585-3535, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.

Reported: 2024-11-01 (November 1, 2024) · Model years: 2014, 2015, 2016, 2017, 2018

Winnebago Industries, Inc. (Winnebago) is recalling certain 2014-2018 Sightseer, Itasca Sunova, 2016-2025 Forza, Vista, and Itasca/Winnebago Sunstar, 2015-2025 Adventurer, 2015-2024 Commercial Vehicle, 2015-2028 Itasca Suncruiser, and 2016-2017 Itasca Solei recreational vehicles. The hood bracket adhesive may have been incorrectly applied which can allow the bracket to detach.

Consequence: A detached hood bracket may become a road hazard and increase the risk of a crash.

Remedy: Dealers will inspect and repair as necessary, free of charge. Owner notification letters began being mailed January 31, 2025. Owners may contact Winnebago at 1-800-537-1885. Winnebago's number for this recall is 192.

Reported: 2015-09-21 (September 21, 2015) · Model years: 2015, 2016

Winnebago Industries, Inc. (Winnebago) is recalling certain model year 2015-2016 Winnebago Sightseer and Itasca Sunova motorhomes with a D35G floorplan, manufactured March 19, 2015, to July 15, 2015. In the affected vehicles, the wiring harness behind the panel board may be pinched or damaged when the left rear slideout room is retracted due to insufficient clearance.

Consequence: A damaged or pinched wiring harness increases the risk of a fire.

Remedy: Winnebago will notify owners, and dealers will inspect the wiring harness for damage, repairing it as necessary. Additionally, the harness attachment point will be relocated to provide the harness extra clearance. These repairs will be performed free of charge. The recall began on November 5, 2015. Owners may contact Winnebago customer service number at 1-641-585-3535.

Reported: 2015-10-16 (October 16, 2015) · Model years: 2015, 2016

Winnebago Industries, Inc (Winnebago) is recalling certain model year 2015-2016 Winnebago Brave, Sightseer, Vista and Adventurer motorhomes and Itasca Tribute, Sunova, Sunstar, and Suncruiser motorhomes manufactured from July 13, 2015, through October 6, 2015. The affected vehicles, built on Ford chassis, can be shifted out of 'PARK' without applying the brakes, due to an incorrect shift cable bracket and an improper shift cable adjustment.

Consequence: If the vehicle can be shifted into reverse without the brakes being applied, the vehicle may unintentionally move, increasing the risk of a crash.

Remedy: Ford will notify owners, and Ford dealers will replace the transmission shift control bracket and adjust the transmission shift cable, free of charge. The recall began on November 12, 2015. Owners may contact Winnebago customer service at 1-641-585-3535 or Ford customer service at 1-866-436-7332.

Reported: 2015-12-22 (December 22, 2015) · Model years: 2015, 2016

Winnebago Industries, Inc. (Winnebago) is recalling certain model year 2015-2016 Winnebago Sightseer, Vista, and Adventurer motorhomes manufactured August 1, 2014 through August 31, 2015, and 2015-2016 Itasca Sunova, Sunstar, and Suncruiser motorhomes manufactured August 1, 2014, through August 31, 2015. The affected vehicles have electrically operated entry/exit steps that may extend down and out while the vehicle is moving.

Consequence: If the steps extend while the vehicle is being driven, the steps may strike a person or another vehicle, increasing the risk of injury or a crash.

Remedy: Winnebago will notify owners, and dealers will replace the step switch connections at no charge. The recall began on February 12, 2016. Owners may contact Winnebago customer service at 1-641-585-3535.

Reported: 2024-10-01 (October 1, 2024) · Model years: 2016, 2017, 2018

Winnebago Industries, Inc. (Winnebago) is recalling certain 2013-2017 Tour, 2013-2018 Journey, 2014-2022 Forza, 2015-2016 Brave, 2015-2019 Grand Tour, 2015-2021 Vista, 2016-2018 Adventurer, Sightseer, 2016-2021 Commercial Vehicle, 2018-2021 Intent, Sunstar, 2018-2020 Horizon, Itasca 2013-2017 Ellipse, Meridian, 2014-2017 Solei, 2015-2016 Tribute, 2015-2018 Sunstar, 2016-2018 Suncruiser, and Sunova motorhomes. The turn signals may have a smaller than required luminous lens area. As such these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: A small lens can make it difficult for other drivers to see the turn signal, increasing the risk of a crash.

Remedy: Dealers will replace the turn signals, free of charge. Owner notification letters were mailed April 17, 2026. Owners may contact Winnebago Customer Care at 1-800-537-1885. Winnebago's number for this recall is 189.