48 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
67V117000 · Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings
Reported: 1967-12-07 (December 7, 1967) · Model years: 1968
NHTSA campaign record ↗69V001000 · Seat Belts:Front:Buckle Assembly
Reported: 1969-08-07 (August 7, 1969) · Model years: 1969
NHTSA campaign record ↗74V050000 · Fuel System, Gasoline:Storage:Tank Assembly:Mounting
Reported: 1974-03-25 (March 25, 1974) · Model years: 1974
NHTSA campaign record ↗77V115000 · Electrical System:Horn
Reported: 1977-07-28 (July 28, 1977) · Model years: 1977
THE INVOLVED VEHICLES HAVE STEERING WHEEL CENTER HUBS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 107, "REFLECTING SURFACES". THE HORN BUTTON CAP AND THE LOCK LEVER HAVE A BRUSHED CHROME FINISH. THE SURFACE REFLECTIVITY OF THIS FINISH ON SOME OF THESE HORN BUTTON CAPS AND LOCK LEVERS IS APPROXIMATELY TWICE THE MAXIMUM REFLECTIVITY ALLOWED BY THE STANDARD.
Remedy: DEALER WILL REPLACE THE CAP AND LEVER WITH PARTS PAINTED TO MATCH THE INTERIOR TRIM COLOR AT NO COST TO OWNER.
NHTSA campaign record ↗83V064000 · Service Brakes, Hydraulic:Foundation Components:Disc:Caliper
Reported: 1983-07-07 (July 7, 1983) · Model years: 1984
ATTACHING BOLTS WERE MISTAKENLY COATED WITH A SLIPPERY MATERIAL DURING PRODUCTION. THIS MATERIAL WILL ACT AS A LUBRICANT AND BOLTS MAY LOOSEN AND EVENTUALLY FALL OFF.
Remedy: DEALER WILL INSTALL NEW CALIPER BRACKET BOLTS FREE OF CHARGE.
NHTSA campaign record ↗83V081000 · Electrical System:12v/24v/48v Battery:Cables
Reported: 1983-08-25 (August 25, 1983) · Model years: 1984
THE INSULATION OF THE BATTERY CABLE, BECAUSE OF ITS POSITION, RUBS AGAINST SOME OF THE ENGINE WIRING COMPONENTS. ONCE THE INSULATION IS WORN THROUGH, THE BATTERY COULD RAPIDLY DISCHARGE.
Remedy: DEALER WILL INSTALL A NEW ENGINE HARNESS RETAINER BRACKET, PROTECTIVE CONDUIT, CABLE CLIPS, A CABLE TIE STRAP AND WILL REPOSITION THE TERMINALS ON THE GROUND STUD ON ALL INVOLVED VEHICLES.
NHTSA campaign record ↗85V029000 · Vehicle Speed Control
Reported: 1985-03-19 (March 19, 1985) · Model years: 1984
THE CRUISE CONTROL VACUUM SOLENOID VALVES MAY MALFUNCTION AT ANY TIME THE ENGINE IS RUNNING AND THE CRUISE CONTROL IS ENGAGED AND CAUSE UNEXPECTED ENGINE ACCELERATION. CONSEQUENCE OF DEFECT: LOSS OF ACCELERATOR CONTROL COULD RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: INSTALL AND RELOCATE A NEW CRUISE CONTROL SERVO ASSEMBLY.
NHTSA campaign record ↗85V118000 · Power Train:Driveline:Differential Unit
Reported: 1985-10-01 (October 1, 1985) · Model years: 1984
CARS MAY LOSE THE WIRE SNAP RINGS THAT HOLD THE DIFFERENTIAL CROSS SHAFT IN POSITION IN THE REAR AXLE DIFFERENTIAL CASE ASSEMBLY, ALLOWING THE SHAFT TO MOVE. CONSEQUENCE OF DEFECT: THE CROSS SHAFT MOVEMENT COULD CAUSE THE SHAFT TO CONTACT THE CARRIER OR PINION TEETH, POSSIBLY LOCKING UP THE REAR WHEELS AND RESULT IN A CRASH WITHOUT PRIOR WARNING.
Remedy: INSTALL A REAR AXLE DIFFERENTIAL CROSS SHAFT RETAINING KIT.
NHTSA campaign record ↗91V143000 · Seat Belts:Front:Anchorage
Reported: 1991-09-04 (September 4, 1991) · Model years: 1984, 1985, 1986, 1987, 1988, 1989, 1990, 1991
UNDER CERTAIN VEHICLE OPERATIONS AND OCCUPANT USAGE CONDITIONS, THE SAFETY BELTS CAN LOCKUP OR JAM IN THE SAFETY BELT RETRACTOR.
Consequence: IF LOCKUP OCCURS, IT IS IMPOSSIBLE TO PULL BELT OUT OFTHE RETRACTOR. THE OCCUPANT OF A SEAT WITH AN UNUSABLE SAFETY BELT ISSUBJECT TO INCREASED RISK OF INJURY OR DEATH IN THE EVENT OF A SUDDEN STOP ORACCIDENT.
Remedy: REPLACE THE SAFETY BELTS IF THE LOCKUP OCCURS.
NHTSA campaign record ↗86V056000 · Exterior Lighting:Headlights:Switch
Reported: 1986-04-28 (April 28, 1986) · Model years: 1986
THE PUSH-PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING. NOTE: ALSO, SEE NHTSA CAMPAIGN NUMBER 86V131000.
Remedy: REPLACE HEADLIGHT SWITCH AS NECESSARY.
NHTSA campaign record ↗86V120000 · Service Brakes, Hydraulic:Foundation Components:Master Cylinder
Reported: 1986-08-26 (August 26, 1986) · Model years: 1986
SEVERE AND UNUSUAL BRAKING CONDITIONS MAY CAUSE DAMAGE TO THE BRAKE MASTER CYLINDER CENTER VALVE. CONSEQUENCE OF DEFECT: IF SUFFICIENT DAMAGE OCCURS, LOSS OF FRONT BRAKES MAY OCCUR WITH INCREASED PEDAL TRAVEL AND REDUCED BRAKING ABILITY. THE REDUCTION OF BRAKING ABILITY AT A TIME WHEN MINIMUM STOPPING DISTANCE IS REQUIRED COULD RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
Remedy: NEW MASTER CYLINDER CENTER VALVE AND RELATED PARTS WILL BE INSTALLED.
NHTSA campaign record ↗88V017000 · Wheels:Hubcap/Cover
Reported: 1988-02-09 (February 9, 1988) · Model years: 1988
MISSING WELD THAT ATTACHES WHEEL CENTER TO THE RIM COULD ALLOW WHEEL CENTER TO SEPARATE FROM THE RIM.
Consequence: THIS COULD RESULT IN PARTIAL LOSS OF STEERING CONTROLAND BRAKES, LOSS OF TIRE AIR PRESSURE, AND SUDDEN CHANGE IN VEHICLE DIRECTION,WHICH COULD RESULT IN CRASH WITHOUT PRIOR WARNING.
Remedy: REPLACE WHEELS WITH MISSING WELDS.
NHTSA campaign record ↗90V032000 · Suspension:Rear:Springs:Leaf Spring Assembly
Reported: 1990-02-12 (February 12, 1990) · Model years: 1988, 1989
REAR WHEEL TIE ROD ASSEMBLY MAY FATIGUE AND COULD FRACTURE AT THE INBOARD BEARING DUE TO HIGH INNER JOINT ROCKING TORQUE.
Consequence: FRACTURE IN THIS ASSEMBLY COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH WITHOUT PRIOR WARNING.
Remedy: REPLACE FAULTY TIE ROD ASSEMBLIES.
NHTSA campaign record ↗90V008000 · Fuel System, Gasoline:Delivery:Hoses, Lines/Piping, And Fittings
Reported: 1990-01-22 (January 22, 1990) · Model years: 1990
FUEL FEED AND RETURN LINE CONNECTORS HAVE INCORRECT LINE END FLARE CONFIGURATIONS.
Consequence: LINE ENDS COULD CRACK CAUSING A FUEL LEAK THAT COULD RESULT IN AN ENGINE COMPARTMENT FIRE.
Remedy: INSTALL NEW FUEL LINES WITH CORRECT END FLARE CONFIGURATION.
NHTSA campaign record ↗92V160000 · Steering:Hydraulic Power Assist:Hose, Piping, And Connections
Reported: 1992-11-08 (November 8, 1992) · Model years: 1992, 1993
THE POWER STEERING GEAR INLET HOSE ON THESE VEHICLES CAN FRACTURE, CAUSING POWER STEERING FLUID TO SPRAY FROM HOSE INTO THE ENGINE COMPARTMENT.
Consequence: THE POWER STEERING FLUID IS FLAMMABLE AND COULD CAUSEAN UNDERHOOD FIRE IF EXPOSED TO A SOURCE OF IGNITION.
Remedy: REPLACE THE POWER STEERING GEAR INLET HOSE WITH AN IMPROVED DESIGN.
NHTSA campaign record ↗00V111000 · Seat Belts:Front
Reported: 2000-04-17 (April 17, 2000) · Model years: 1997, 1998, 1999, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LAP BELT WEBBING CAN TWIST ALLOWING THE WEBBING TO BECOME JAMMED IN THE RETRACTOR.
Consequence: WHEN THE BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE SEAT BELT MAY BE UNUSABLE.
Remedy: DEALERS WILL INSTALL INSERTS TO THE BELT WEB GUIDE OF EACH LAP BELT RETRACTOR.
NHTSA campaign record ↗04V060000 · Steering:Column Locking:Anti-Theft Device
Reported: 2004-02-09 (February 9, 2004) · Model years: 1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH ELECTRONIC COLUMN LOCK SYSTEMS (ECL), WHEN THE IGNITION SWITCH IS TURNED TO "LOCK," THE ECL SYSTEM PREVENTS TURNING OF THE STEERING SYSTEM. WHEN THE VEHICLE IS STARTED, THE ECL UNLOCKS THE STEERING SYSTEM. THE VEHICLE IS DESIGNED SO THAT IF THE COLUMN FAILS TO UNLOCK WHEN THE VEHICLE IS STARTED AND THE CUSTOMER TRIES TO DRIVE, THE FUEL SUPPLY WILL BE SHUT OFF SO THAT THE VEHICLE CANNOT MOVE WHEN THE VEHICLE CANNOT BE STEERED. IF VOLTAGE AT THE POWERTRAIN CONTROL MODULE IS LOW OR INTERRUPTED, HOWEVER, THE FUEL SHUT OFF MAY NOT OCCUR AND THE VEHICLE CAN BE ACCELERATED WHILE THE STEERING SYSTEM IS LOCKED. ALSO WHEN THE CONTROL SYSTEM SHOWS THAT THE ECL IS UNLOCKED AND THE VEHICLE IS BEING DRIVEN, THE LOCK PIN LOCATION CAN VARY. DEPENDING ON THE LOCATION OF THE LOCK PLATE RELATIVE TO THE SWITCH TRANSITION POINT, THERE COULD THEN BE CONTACT BETWEEN THE LOCK PLATE AND PIN CAUSING THE STEERING TO LOCK WHILE DRIVING .
Consequence: IF THIS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING.
Remedy: ON VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, THE DEALER WILL DISABLE THE STEERING COLUMN LOCK BY REMOVING THE COLUMN LOCK PLATE. WHEN THE IGNITION KEY IS REMOVED, THE TRANSMISSION SHIFTER WILL LOCK BUT THE STEERING COLUMN WILL NOT LOCK. ON VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION, THE DEALER WILL REPROGRAM THE POWERTRAIN CONTROL MODULE, PERFORM A DIMENSIONAL CHECK OF THE COLUMN LOCK AND, IF NECESSARY, REPLACE THE LOCK PLATE. THE STEERING COLUMN ON THESE VEHICLES WILL CONTINUE TO LOCK WHEN THE KEY IS REMOVED. OWNER NOTIFICATION TO OWNERS OF 1997 VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS BEGAN ON APRIL 26, 2004. OWNERS OF 1998 THROUGH 2004 VEHICLES (EXCEPT 1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED BEGINNING ON AUGUST 2, 2004. THE REMAINING OWNERS (1997-1998 MANUAL TRANSMISSION VEHICLES) WILL BE NOTIFIED LATER IN 2004, WHEN PARTS ARE AVAILABLE. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438.
NHTSA campaign record ↗97V044000 · Suspension:Rear
Reported: 1997-03-20 (March 20, 1997) · Model years: 1997
THE REAR SUSPENSION TIE ROD ASSEMBLY CAN FRACTURE.
Consequence: IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, LOSS OF DIRECTIONAL CONTROL CAN RESULT INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT-HAND REAR SUSPENSION TIE ROD LINKS.
NHTSA campaign record ↗97V104000 · Seat Belts:Front:Anchorage
Reported: 1997-06-28 (June 28, 1997) · Model years: 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELTS IN THESE VEHICLES INCORPORATE AN ENERGY MANAGEMENT LOOP. THIS LOOP IS INADEQUATE TO ABSORB THE NECESSARY FORCES THAT CAN BE EXERTED ON IT. THEREFORE, THE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE ENERGY MANAGEMENT LOOP WILL NOT ABSORB ENOUGH ENERGY, AND INJURY TO THE SEAT OCCUPANT CAN OCCUR.
Remedy: DEALERS WILL REPLACE THE DRIVER AND PASSENGER SIDE SEAT BELT RETRACTOR ASSEMBLIES.
NHTSA campaign record ↗97V105000 · Fuel System, Gasoline:Storage:Tank Assembly
Reported: 1997-06-23 (June 23, 1997) · Model years: 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES HAVE A TORN FUEL TANK SENDING UNIT/PUMP SEAL. THIS CAN CAUSE FUEL ODOR AND/OR LEAKAGE AT THE ATTACHMENT LOCATION.
Consequence: FUEL LEAKAGE FROM A TORN SEAL CAN RESULT IN A FIRE IF AN IGNITION SOURCE IS PRESENT.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT HAND FUEL TANK ASSEMBLIES (INCLUDING FUEL SENDING UNIT AND PUMP).
NHTSA campaign record ↗04V273000 · Steering:Linkages
Reported: 2004-06-09 (June 9, 2004) · Model years: 2004
ON CERTAIN PASSENGER VEHICLES INVOLVED IN THIS CAMPAIGN, THE LOWER CONTROL ARM BALL STUD NUT/WASHER ASSEMBLIES WITH WASHERS WERE MADE OF THE WRONG MATERIAL. THE WASHERS MAY FRACTURE AND BECOME LOOSE OR FALL AWAY FROM THE VEHICLE, REDUCING CLAMP LOAD. SEPARATION OF THE CONTROL ARM BALL STUD AND STEERING KNUCKLE, DUE TO DISENGAGEMENT OF THE TAPERED ATTACHMENT AND RETAINING NUT, IS POSSIBLE.
Consequence: IF THE CONTROL ARM SEPARATES FROM THE KNUCKLE, THE AFFECTED CORNER OF THE VEHICLE WILL DROP AND THE CONTROL ARM WOULD BE FORCED DOWNWARD, CONTACTING THE WHEEL. THE AFFECTED WHEEL COULD TILT OUTWARD AND CREATE A DRAGGING ACTION THAT WOULD TEND TO SLOW THE VEHICLE AND CREATE A TENDENCY FOR THE VEHICLE TO TURN IN THE DIRECTION OF THE AFFECTED WHEEL. IN EXTREME SITUATIONS, THE AFFECTED WHEEL ASSEMBLY COULD SEPARATE FROM THE VEHICLE. SEPARATION OF THE WHEEL ASSEMBLY WOULD ALSO SEVER THAT WHEEL;S HYDRAULIC BRAKE HOSE AND RESULT IN DIMINISHED BRAKING PERFORMANCE OF THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT THE BALL STUD JOINTS AND MEASURE THE TORQUE OF THE NUT FOR ALL FRONT LOWER CONTROL ARMS IN ALL MODELS AFFECTED AS WELL AS THE REAR LOWER CONTROL ARMS ON THE XLR AND CORVETTE. IF THE TORQUE IS NOT AT SPECIFICATION, THE DEALERS WILL REPLACE THE BALL STUD, THE KNUCKLE, AND THE NUT. IF THE TORQUE IS AT SPECIFICATION, THE DEALERS WILL REPLACE THE NUT/WASHER ASSEMBLY ONLY. THE RECALL WILL BEGIN ON AUGUST 25, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339 OR CHEVROLET AT 1-800-630-2438.
NHTSA campaign record ↗04V525000 · Service Brakes, Hydraulic:Foundation Components:Hoses, Lines/Piping, And Fittings
Reported: 2004-11-03 (November 3, 2004) · Model years: 2005
CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH ONE OR BOTH REAR BRAKE HYDRAULIC LINES THAT CAN COME IN CONTACT WITH OR BE AFFECTED BY HEAT FROM THE LEFT ENGINE EXHAUST MANIFOLD AND THE LEFT EXHAUST PIPE. THE BRAKE FLUID COULD REACH ELEVATED TEMPERATURES AND BOIL.
Consequence: IF THE BRAKE FLUID BOILS IN A REAR BRAKE LINE, THE EFFECTIVENESS OF THE REAR BRAKE SYSTEM WOULD BE REDUCED WHICH COULD RESULT IN A BRAKE LINE LEAK AND LOSS OF BRAKE FLUID. IF ENOUGH FLUID LEAKS FROM THE REAR BRAKE SYSTEM SO THAT BRAKE PEDAL APPLICATION CAN NO LONGER BUILD PRESSURE TO THE REAR BRAKES. THE OPERATOR OF THE VEHICLE WILL EXPERIENCE LIMITED BRAKING WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL (1) INSPECT THE LEFT ENGINE EXHAUST MANIFOLD CLIP FOR PROPER ALIGNMENT AND PLACEMENT ON THE BODY-MOUNTED STUD. IF INCORRECT, THEY WILL REPOSITION THE CLIP ON THE BRAKE LINES AND REINSTALL THE CLIP ON THE STUD; (2) THE DEALER WILL VERIFY THAT BOTH REAR BRAKE LINES HAVE THE PROPER CLEARANCE TO THE LEFT EXHAUST PIPE. THEY WILL REPOSITION THE LINES BY BENDING AS NECESSARY; (3) DEALERS WILL REMOVE THE MACHINING TAB FROM THE REAR DIFFERENTIAL HOUSING. ALSO, DEALERS ARE TO INSPECT THE BRAKE LINES FOR WEAR IN THESE RELATED AREAS AND REPAIR OR REPLACE IF THERE IS ANY SIGN OF WEAR-THROUGH ON THE NYLON OVERCOATING. THE RECALL BEGAN ON JANUARY 18, 2005. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2239 OR CHEVROLET AT 1-800-630-2438.
NHTSA campaign record ↗05V455000 · Steering:Hydraulic Power Assist:Hose, Piping, And Connections
Reported: 2005-10-05 (October 5, 2005) · Model years: 2005, 2006
CERTAIN PASSENGER VEHICLES MAY HAVE BEEN BUILT WITH A POWER STEERING HOSE THAT IS NOT TO SPECIFICATION. UNDER EXTREME STEERING MANEUVERS, SUCH AS TURNING THE STEERING WHEEL FULLY TO THE LEFT OR RIGHT WHILE BRAKING, THE HOSE MAY FRACTURE AND LEAK FLUID.
Consequence: IF THIS WERE TO OCCUR, POWER STEERING ASSIST WOULD BE LOST AND INCREASED STEERING EFFORT WOULD BE REQUIRED. ON VEHICLES EQUIPPED WITH HYDRO-BOOST POWER BRAKES, IT COULD ALSO RESULT IN LOSS OF POWER BRAKE ASSIST AND INCREASED BRAKING EFFORT WOULD BE REQUIRED. IF THE POWER STEERING FLUID SPRAY WERE TO SPRAY ONTO HOT ENGINE PARTS, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE POWER STEERING HOSE(S) FOR TWO SUSPECT DATE CODES AND REPLACE THEM IF REQUIRED. THE RECALL WILL BEGIN ON OCTOBER 14, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, ISUZU AT 1-800-255-6727, OR HUMMER AT 1-800-732-5493.
NHTSA campaign record ↗06V181000 · Structure:Body:Roof And Pillars
Reported: 2006-05-24 (May 24, 2006) · Model years: 2005, 2006
ON CERTAIN 2005-2006 CHEVROLET CORVETTES EQUIPPED WITH PAINTED ROOFS, THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE.
Consequence: IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE AND IT COULD STRIKE ANOTHER VEHICLE AND CAUSE INJURY AND PROPERTY DAMAGE.
Remedy: DEALERS WILL INSPECT VEHICLES FREE OF CHARGE FOR POTENTIAL ROOF PANEL-TO- FRAME SEPARATION AND ADD THE SPECIFIED ADHESIVE FOAM OR REPLACE THE ROOF WITH ONE HAVING ADHESIVE FOAM. THE RECALL BEGAN ON OCTOBER 19, 2006. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
NHTSA campaign record ↗09V491000 · Structure:Body:Roof And Pillars
Reported: 2009-12-23 (December 23, 2009) · Model years: 2005, 2006, 2007
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2007 CORVETTE VEHICLES EQUIPPED WITH A REMOVABLE ROOF AND MODEL YEAR 2006 AND 2007 CORVETTE Z06 VEHICLES. THE ADHESIVE BETWEEN THE ROOF PANEL AND THE FRAME MAY SEPARATE. IF THERE IS A PARTIAL SEPARATION, THE DRIVER MAY NOTICE ONE OR MORE SYMPTOMS, SUCH AS A SNAPPING NOISE WHEN DRIVING OVER BUMPS, WIND NOISE, POOR ROOF PANEL FIT, ROOF PANEL MOVEMENT/BOUNCE WHEN A DOOR OR HATCH IS CLOSED, OR A WATER LEAK IN THE HEADLINER.
Consequence: IF THERE IS A COMPLETE SEPARATION, THE ROOF PANEL MAY DETACH FROM THE VEHICLE. IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS BEING DRIVEN, IT COULD STRIKE A FOLLOWING VEHICLE AND CAUSE INJURY AND/OR PROPERTY DAMAGE.
Remedy: DEALERS WILL INSTALL A NEW DESIGN ROOF PANEL FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT WWW.GMOWNERCENTER.COM.
NHTSA campaign record ↗10V172000 · Steering:Column
Reported: 2010-04-26 (April 26, 2010) · Model years: 2005, 2006
GM IS RECALLING CERTAIN MODEL YEAR 2005 AND 2006 CHEVROLET CORVETTE PASSENGER CARS MANUFACTURED BETWEEN MARCH 2004 AND JANUARY 2006 EQUIPPED WITH A TILT AND TELESCOPING STEERING COLUMN (RPO N37). IN RARE CASES, REPEATED MOVEMENT OF THE STEERING COLUMN MAY CAUSE A SIGNAL INTERRUPTION WITHIN THE COLUMN. IF THIS OCCURS, THE MESSAGE, "SERVICE ACTIVE HANDLING SYSTEM" WILL APPEAR IN THE DRIVER INFORMATION CENTER, AND ONE OR MORE OF THE BRAKES MAY APPLY, POSSIBLY CAUSING THE VEHICLE TO PULL TO THE RIGHT OR LEFT.
Consequence: IF THE DRIVER DOES NOT RESPOND TO THE CHANGE IN VEHICLE MOVEMENT, A CRASH COULD OCCUR.
Remedy: GM WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 30, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND GMC AT 1-866-996-9463 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
NHTSA campaign record ↗14V251000 · Exterior Lighting:Headlights | Electrical System:Wiring
Reported: 2014-05-14 (May 14, 2014) · Model years: 2005, 2006, 2007
General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.
Consequence: The loss of low beam headlamp illumination will decrease the driver's visibility, as well as the vehicle's conspicuity to other motorists, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will install a jumper wire to correct this condition, free of charge. The recall began January 2, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 13146. Note: Model year 2008-2013 Chevrolet Corvettes will be covered under customer satisfaction program number 14203 for the same issue.
NHTSA campaign record ↗11V491000 · Structure:Body:Hatchback/Liftgate:Hinge And Attachments
Reported: 2011-10-03 (October 3, 2011) · Model years: 2011, 2012
GENERAL MOTORS (GM) IS RECALLING CERTAIN MODEL YEAR 2011-2012 CHEVROLET CORVETTE COUPE VEHICLES, MANUFACTURED FROM JANUARY 24, 2011, THROUGH SEPTEMBER 1, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS". THE REAR HATCH HINGES MAY NOT MEET THE LOAD REQUIREMENTS SPECIFIED IN THE SAFETY STANDARD.
Consequence: THE REAR HATCH COULD SEPARATE IN THE EVENT OF A CRASH, INCREASING THE RISK OF INJURY.
Remedy: GM WILL NOTIFY OWNERS AND DEALERS WILL REPLACE BOTH REAR HATCH HINGES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
NHTSA campaign record ↗14V299000 · Seat Belts | Air Bags:Frontal:Sensor/Control Module-Inactive | Air Bags
Reported: 2014-06-06 (June 6, 2014) · Model years: 2014
General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Corvette vehicles manufactured April 23, 2014 to April 25, 2014. In the affected vehicles, the Sensing and Diagnostic Module (SDM) may experience an internal short circuit, resulting in the deactivation of the air bags and seat belt pretensioners.
Consequence: If the SDM short circuits, the air bags may not deploy and the seat belt pretensioners may not activate in the event of a crash, increasing the risk of occupant injury.
Remedy: GM will notify owners, and dealers will replace the Sensing and Diagnostic Module (SDM), free of charge. The recall began on August 1, 2014. Owners may contact General Motors customer service at 1-800-222-1020. GM's number for this recall is 14219.
NHTSA campaign record ↗14V342000 · Air Bags
Reported: 2014-06-19 (June 19, 2014) · Model years: 2014
General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Corvette vehicles manufactured November 20, 2013, to March 25, 2014, and equipped with optional sport seats. The seats do not meet internal specifications for injury protection in relation to an unbelted young child.
Consequence: In the event of a crash necessitating side impact air bag deployment, an unbelted young child may be at an increased risk of neck injury.
Remedy: GM will notify owners, and dealers will replace the passenger's side impact air bag, free of charge. The recall is began in early August 2014. Owners should not allow small children to ride in vehicles unbelted or in the front passenger seat. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14240.
NHTSA campaign record ↗14V377000 · Suspension:Rear:Shock Absorber
Reported: 2014-06-26 (June 26, 2014) · Model years: 2014
General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Corvette vehicles manufactured February 12, 2014, to March 14, 2014. Due to an improper weld on the rear shock absorbers, the shock absorber tubes may separate from the shock absorber clevis brackets resulting in a sudden change in vehicle handling.
Consequence: A sudden change in vehicle handling increases the risk of a crash.
Remedy: GM will notify owners, and dealers will replace both of the rear shock absorbers, free of charge. The recall began on August 18, 2014. Owners may contact Chevrolet customer service at 1- 800-222-1020. GM's number for this recall is 14302.
NHTSA campaign record ↗16V651000 · Seat Belts:Pretensioner | Air Bags:Frontal:Sensor/Control Module-Inactive | Air Bags:Frontal
Reported: 2016-09-08 (September 8, 2016) · Model years: 2014, 2015, 2016, 2017
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
NHTSA campaign record ↗17V437000 · Seat Belts:Pretensioner | Air Bags:Frontal:Sensor/Control Module-Inactive | Air Bags:Frontal
Reported: 2017-07-10 (July 10, 2017) · Model years: 2014, 2015, 2016, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Consequence: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
NHTSA campaign record ↗14V568000 · Parking Brake
Reported: 2014-09-17 (September 17, 2014) · Model years: 2015
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Corvette vehicles manufactured August 20, 2014, to September 4, 2014. In the affected vehicles, only one of the rear parking brake cables may be fully seated and engaged, resulting in the parking brake only operating on one of the rear park brake drums. Without the parking brake working on both rear wheels, the vehicle may roll away if parked on a steep gradient. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 135, "Light Vehicle Brake Systems."
Consequence: If the parking brake cable isn't fully seated and engaged on both of the rear park brake drums, the vehicle may roll away if parked on a steep gradient, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will inspect and correct the park brake cable installation, as necessary, free of charge. The recall began on October 31, 2014. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14620.
NHTSA campaign record ↗14V570000 · Air Bags
Reported: 2014-09-19 (September 19, 2014) · Model years: 2015
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Corvette vehicles manufactured August 20, 2014, to August 27, 2014. In the event of a driver frontal air bag deployment, the driver air bag module back plate may fracture, allowing the driver air bag to separate from the steering wheel.
Consequence: An air bag that separates from the steering wheel may increase the risk of injury to the driver in the event of a crash.
Remedy: GM will notify owners, and dealers will replace the driver side air bag, free of charge. The recall began on October 29, 2014. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14594.
NHTSA campaign record ↗15V031000 · Suspension
Reported: 2015-01-26 (January 26, 2015) · Model years: 2015
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Corvette vehicles manufactured September 26, 2014, to October 2, 2014. In the affected vehicles the toe link outer ball joint on the rear suspension may not have been properly tightened during the assembly process. The Toe link may loosen with the vehicle use and eventually separate.
Consequence: A toe link separation can result in a reduction in vehicle stability and steering control, increasing the risk of a vehicle crash.
Remedy: GM will notify owners, and dealers will inspect and replace any damaged parts, free of charge. The recall began February 23, 2015. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet). GM's number for this recall is 14857.
NHTSA campaign record ↗19V086000 · Steering:Electric Power Assist System
Reported: 2019-02-07 (February 7, 2019) · Model years: 2017
General Motors LLC (GM) is recalling certain 2016-2018 Cadillac CTS, and 2017 Cadillac ATS, Chevrolet Camaro, and Chevrolet Corvette vehicles. The electric power steering (EPS) assist system may fail.
Consequence: Loss of power steering assist would require a higher steering effort, especially at lower speeds, which may increase the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the power steering gear assembly, free of charge. The recall began June 13, 2019. GM' number for this recall is N182182760.
NHTSA campaign record ↗25V175000 · Steering:Electric Power Assist System
Reported: 2025-03-20 (March 20, 2025) · Model years: 2017, 2018
General Motors LLC (GM) is recalling certain 2016-2018 Cadillac CTS, 2017-2018 Cadillac ATS, Chevrolet Camaro, and Chevrolet Corvette vehicles. The electric power steering (EPS) assist may fail.
Consequence: A loss of power steering assist can require greater steering effort, especially at low speeds, increasing the risk of a crash.
Remedy: Dealers will replace the power steering gear assembly, free of charge. Owner notification letters were mailed April 15, 2025. Owners may contact Cadilac customer service at 1-800-333-4223 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252497020.
NHTSA campaign record ↗18V360000 · Air Bags: Air Bag/Restraint Control Module
Reported: 2018-05-31 (May 31, 2018) · Model years: 2019
General Motors LLC (GM) is recalling certain 2019 Chevrolet Corvette ZR1 vehicles. Hard braking or acceleration may cause the sensing diagnostic module (SDM) to enter a fault state. As a result, the SDM will not provide crash sensing or deploy the necessary air bags in the event of a crash.
Consequence: In the event of a crash, if the air bags do not deploy as designed, the occupants have an increased risk of injury.
Remedy: GM will notify owners, and dealers will reprogram the SDM with updated software, free of charge. The recall began on June 29, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18195.
NHTSA campaign record ↗20V461000 · Electrical System:Software | Latches/Locks/Linkages:Trunk Lid:Lock
Reported: 2020-08-06 (August 6, 2020) · Model years: 2020
General Motors LLC (GM) is recalling certain 2020 Chevrolet Corvette vehicles. The release button located inside the front trunk compartment may not function after the vehicle has been shut off for ten minutes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."
Consequence: If a person climbs inside the front trunk compartment and closes the lid, they may be trapped inside, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will update the software in the vehicle's Body Control Module (BCM) to allow the release switch to always work, free of charge. Owners also may allow the vehicle to be remedied via an Over-The-Air (OTA) software update. The recall began September 3, 2020. Owners may contact GM customer service at 1-866-522-9559. GM's number for this recall is N202309350.
NHTSA campaign record ↗20V489000 · Electrical System:Software | Structure:Body:Trunk Lid
Reported: 2020-08-18 (August 18, 2020) · Model years: 2020
General Motors LLC (GM) is recalling certain 2020 Chevrolet Corvette vehicles. Despite visual and audible warnings, the vehicle can be driven with the front trunk lid unlatched.
Consequence: An unlatched hood can open when driving above a certain speed, obstructing the driver's forward view and increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will update the software in the vehicle's Body Control Module to limit the vehicle speed to 26 mph when the hood is not completely closed and latched, free of charge. In addition, the operation of the hood release on the key fob will be modified to reduce the likelihood of inadvertent hood release actuations. Owners also may allow the vehicle to be remedied via an Over-The-Air (OTA) software update. The recall began September 24, 2020. Owners may contact GM customer service at 1-866-522-9559. GM's number for this recall is N202311160.
NHTSA campaign record ↗20V581000 · Seat Belts:Front:Retractor | Seat Belts
Reported: 2020-09-24 (September 24, 2020) · Model years: 2020
General Motors LLC (GM) is recalling certain 2020 Chevrolet Corvette vehicles. The driver's seat belt retractor may not lock as intended during a crash.
Consequence: In the event of a crash, if the driver's seat belt fails to lock, there is an increased risk of injury.
Remedy: GM will notify owners, and dealers will replace the driver's side seat-belt retractor, free of charge. The recall began October 15, 2020. Owners may contact GM customer service at 1-866-522-9559. GM's number for this recall is N202307690.
NHTSA campaign record ↗20V588000 · Service Brakes
Reported: 2020-09-24 (September 24, 2020) · Model years: 2020
General Motors LLC (GM) is recalling certain 2020 Chevrolet Corvette and Cadillac CT4, CT5 and XT4, 2021 Chevrolet Trailblazer, and 2020-2021 Buick Encore GX vehicles. Sensor connection contamination in the electronic brake boost system may cause an interruption of communication between the sensor and the brake boost system.
Consequence: If communication with the sensor is interrupted, the electronic brake boost assist could be lost. Extra pedal force will be required to slow and stop the vehicle, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the electronic brake boost module, free of charge. The recall began December 9, 2020. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-333-4223, or Buick customer service at 1-800-521-7300. GM's number for this recall is A202307260.
NHTSA campaign record ↗21V421000 · Air Bags:Srs Malfunction Warning Lamp/Light | Electrical System:Software
Reported: 2021-06-10 (June 10, 2021) · Model years: 2021
General Motors, LLC (GM) is recalling certain 2021 Buick Envision, Cadillac CT4, CT5, Escalade, Escalade ESV, Chevrolet Tahoe, Corvette, Suburban, GMC Yukon, Yukon XL vehicles. The communications gateway module incorrectly processes a loss of communication with the sensing diagnostic module (SDM), causing the air bag malfunction indicator light to inconsistently illuminate.
Consequence: The air bag malfunction indicator light may fail to warn the driver of a problem with the air bag, increasing the risk of injury.
Remedy: The communications gateway module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed on July 1, 2021. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N212338110.
NHTSA campaign record ↗22V091000 · Power Train:Driveline:Driveshaft
Reported: 2022-02-17 (February 17, 2022) · Model years: 2021, 2022
General Motors, LLC (GM) is recalling certain 2021-2022 Chevrolet Corvette vehicles. The rear half-shaft assemblies may be missing one or more ball bearings, which can result in a loss of drive power.
Consequence: An unexpected loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the left or right rear half-shaft assemblies, as necessary, free of charge. Owner notification letters are expected to be mailed April 4, 2022. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212351320.
NHTSA campaign record ↗25V536000 · Fuel System, Gasoline
Reported: 2025-08-21 (August 21, 2025) · Model years: 2023, 2024, 2025
General Motors, LLC (GM) is recalling certain 2023–2026 Chevrolet Corvette vehicles equipped with a left-side radiator/fan combination. Excess fuel may spill into the vehicle fuel-filler pocket during refueling and leak onto an ignition source.
Consequence: A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will install a shield to divert spilled fuel, free of charge. Owner notification letters were mailed November 14, 2025. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252514930.
NHTSA campaign record ↗24V418000 · Seat Belts:Front:Retractor
Reported: 2024-06-06 (June 6, 2024) · Model years: 2024, 2025
General Motors, LLC (GM) is recalling certain 2024-2025 Chevrolet Corvette vehicles. The driver and/or passenger seat belt retractors may lock in a stowed position and become inaccessible to occupants.
Consequence: An inaccessible seat belt that cannot restrain an occupant, increases the risk of injury in a crash.
Remedy: Dealers will replace the driver and/or passenger seat belt retractors, free of charge. Owner notification letters were mailed September 19, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242441390.
NHTSA campaign record ↗26V213000 · Exterior Lighting:Lighting Control Module:Software | Exterior Lighting:Turn Signal
Reported: 2026-04-02 (April 2, 2026) · Model years: 2025
General Motors, LLC (GM) is recalling certain 2026 Chevrolet Corvette ZR1X Coupe, Corvette ZR1X Convertible, Corvette Coupe E-Ray, Corvette Convertible E-Ray, Corvette Convertible, Corvette Coupe, 2025 Corvette E-Ray Coupe, Corvette E-Ray Convertible, Corvette Convertible, and Corvette Coupe vehicles. A software error may prevent detection of a rear turn signal light failure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: The driver may be unaware that the turn signal is not working, increasing the risk of a crash.
Remedy: The lighting control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are scheduled to be mailed May 18, 2026. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252541250. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov April 2, 2025.
NHTSA campaign record ↗