| Visibility/Wiper | 146.1%ODI 11451437The Wiper Motor or electrical controlling the Wiper Motor. When the two high wiper blade settings are selected, the wipers run for around 30-40 seconds, then slow down and eventually stop. You can watch it happen. This has happened while having snow and rain on my windshield. In order to get them to start going again full speed you need to turn the switch. I feel this takes my focus off of the road during unfriendly road conditions and puts me and others at risk. The condition has been reproduced by my dealership and I have had my truck to the … Look up ODI 11451437 at NHTSA ↗ | 6517.3%ODI 11458921Wipers would not stay working as they should on any setting during heavy snow, sleet, and rain. Vehicle has several intermittent settings, as well as (2) continuous wiping settings. The all settings would work as they should for around 60 seconds, then slow down to a very slow intermittent wipe. Each time a setting was changed it would work as it should for 60 seconds before slowing to a very slow intermittent wipe. This was all happening while moving, with heavy precipitation (rain/sleet/snow mix). The safety issue was having to mess with… Look up ODI 11458921 at NHTSA ↗ | 9039.8%ODI 11499597The wipers on low mode stop working after about 30 seconds, requiring to turn off/on again or try the higher wiper speed. On a rainy day, when the wipers stopped there was near zero visibility. There were now warning lights when they stopped working. I see many other 2023 Ford Bronco report similar issues online; however I see no responses or issue acknowledgement from Ford. It is very scary when the wipers stop; especially during a moderate or heavy rain event. My Bronco was purchased week 3 December 2022 and the problem happened during my … Look up ODI 11499597 at NHTSA ↗ | 34.0%ODI 11695322Went out to start the vehicle one afternoon to notice a Crack from the outside passenger edge by the frame. Nothing hit the windshield and just a single line of Crack spread from one side of the windshield straight across took to ford to be told that while they couldn't see an impact they wouldn't cover it under warranty be cause they couldn't prove it was their fault Look up ODI 11695322 at NHTSA ↗ | 35.8%ODI 11739412I am filing a safety complaint regarding repeated windshield cracking on my new 2025 Ford Bronco. I purchased the vehicle approximately 2 months ago. Since purchase, the vehicle has experienced 3 separate windshield cracks under normal commuting use only. The vehicle has not been used off-road or in extreme driving conditions. The most concerning issue is that after the windshield was replaced, the replacement windshield developed another crack within approximately 24 hours of installation. The dealership has repeatedly classified the damage as… Look up ODI 11739412 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Engine | 6930.1%ODI 11448171The 2.7 L engine failed going down the interstate in the middle lane. Complete loss of power. Was fortunate to be able to coast to the shoulder. Dealer says the engine failed and needs to be replaced. Look up ODI 11448171 at NHTSA ↗ | 5213.8%ODI 11463408 · 25 miEngine failure with 25 miles on the odometer. The dealer inspected it and reported that a piston broke and it needs a new engine. A low engine oil pressure warning came on and the check engine light. Look up ODI 11463408 at NHTSA ↗ | 198.4%ODI 11518527While at a stop with vehicle running, the vehicle sputters and stalls when trying to accelerate/start moving. This has happened multiple times when stopped at an intersection and creating a safety hazard for the occupants of the vehicle. Multiple attempts to restart it have to be made and it eventually gets going again but this is very dangerous to be stalled at a busy intersection. Vehicle is going into the dealer to be checked out this week. The only message we have seen is "Manual Restart Required" on the instrument panel. Look up ODI 11518527 at NHTSA ↗ | 68.0%ODI 11639961 · 9,929 miThe contact owns a 2024 Ford Bronco. The contact stated that after parking and turning off the vehicle, the "Steering Assist Fault, Service Required" message was displayed. The message disappeared after restarting the vehicle. The vehicle was taken to the dealer, but the dealer was unable to duplicate the failure. The failure recurred while pressing the Auto Start/Stop button without depressing the brake pedal. The engine revved abnormally loud while the vehicle was parked. The messages "Steering Assist Fault, Service Required", "Pre-Collision … Look up ODI 11639961 at NHTSA ↗ | 917.3%ODI 116794702025 Bronco Sport Safety Recalls* Replace instrument panel cluster Recall incomplete Block heater element replacement Recall incomplete Cylinder head replacement Recall incomplete Cylinder head inspectionreplacement Recall incomplete DO NOT DRIVE! RECOMMENDED TO REPORT NATIONAL ALERT FOR OWNERS OF THIS VEHICLE TYPE. INVESTOR REPORTING FOR BROADCAST RECALL ALERT! Look up ODI 11679470 at NHTSA ↗ | 112.5%ODI 11743709Description On your vehicle, it may be possible that one or more engine camshaft roller finger followers were not properly installed at the time of engine assembly. Safety Risk An improperly installed engine camshaft roller finger follower may result in engine failure, resulting in a no-start condition or a loss of motive power. A loss of motive power increases the risk of a crash. Your vehicle may also experience engine ticking or tapping noise, and or a low-volume oil leak due to this condition. Remedy A remedy is not yet available. Ford… Look up ODI 11743709 at NHTSA ↗ |
|---|
| Electrical System | 2711.8%ODI 11451437The Wiper Motor or electrical controlling the Wiper Motor. When the two high wiper blade settings are selected, the wipers run for around 30-40 seconds, then slow down and eventually stop. You can watch it happen. This has happened while having snow and rain on my windshield. In order to get them to start going again full speed you need to turn the switch. I feel this takes my focus off of the road during unfriendly road conditions and puts me and others at risk. The condition has been reproduced by my dealership and I have had my truck to the … Look up ODI 11451437 at NHTSA ↗ | 3810.1%ODI 11477079Windows don’t drop down when opening the door, and they don’t rise when closing the door as they used to do it. Brake light came on and brakes look good no one is taking responsibility. Look up ODI 11477079 at NHTSA ↗ | 229.7%ODI 115062582nd day of ownership and rear view camera failed. Called Ford and they said it was two months until they have an appointment. Look up ODI 11506258 at NHTSA ↗ | 1824.0%ODI 11635207Since I purchased my vehicle I noticed that the left blinker would turn on sometimes when I put my right blinker on and made a right turn. Usually when you use your right blinker and make a right hand turn, as soon as your vehicle straightens out the blinker should then go off. Instead, this triggers the left blinker to turn on by itself. I am very concerned for my safety and my children's safety as others my think I am turning and I am not. I actually just got off the phone with the department and also got your email address, and will also ema… Look up ODI 11635207 at NHTSA ↗ | 1426.9%ODI 11655457When starting my commute to work and when returning home, the instrument panel and gauges display would not turn on. After power/engine restart and open/close driver door, I drove off and about 10 minutes into drive the instrument panel and gauges display started working. On the way to work I pulled over and took a photo. On the way home I sat in parking lot at work and videoed trying to get display to work. Vehicle security system was installed the day *after* the display failure, 04/18/2025. Look up ODI 11655457 at NHTSA ↗ | 225.0%ODI 11734948The 2026 Ford Bronco Outer Banks instrument cluster has gone blank on two occasions (4/3/26 and 4/23/29). The first time the service department at Joe Mahan Ford, Paris, TN reported the display returned when connected to thier computer, but kept the Bronco for several days trying to replicate the condition. I returned it to the dealer for the same fault on 4/27/26 and it is still in the shop. With the Cluster blank the gauges, speedometer, cruise control, lane warning and assist are not operational. Speed limit and travel speeds are visible on … Look up ODI 11734948 at NHTSA ↗ |
|---|
| Unknown Or Other | 2812.2%ODI 11439274MY FRONT WINDSHIELD HAS CRACKED IN A MANNER THAT IS UNSAFE. IT HAS 2 IDENTICAL CRACKS ON EACH SIDE. SMALL ROCKS HIT THE GLASS AND CAUSED INSTANT CRACKS WELL OVER 8 INCHES IN LENGTH. I FEEL THAT THE GLASS IS NOT IMPACT RATED CORRECTLY OR TOO THIN. I HAVE NEVER SEEN A WINDSHIELD CRACK LIKE THIS FROM THE IMPACT OF A SMALL ROCK. THERE HAVE BEEN MANY COMPLAINTS ON ONLINE FORUMS OF THESE WINDSHIELDS CRACKING ON THE NEW BRONCO. Look up ODI 11439274 at NHTSA ↗ | 4110.9%ODI 11463750I purchased this vehicle from Portsmouth Ford in Portsmouth NH on January 27, 2022. I brought the vehicle into AutoFair Ford (Manchester, NH) on March 16, 2022 as there was a rattling in the engine (at approximately 1519 Miles). I have not seen the vehicle since. The vehicle has been inspected by the mechanics at AutoFair Ford. They attempted a repair job but the sound was still present. Apparently the engine needs to be either redone or redesigned and Ford is not really giving any good answers as to even when this may be completed. The… Look up ODI 11463750 at NHTSA ↗ | 198.4%ODI 11513648Emergency brake failure. I have a very slight slope on my driveway. My car rolled halfway down my driveway. I assumed I did something wrong although I knew I had the car in gear with the E brake on. Two hours later I came back from an errand parked on my driveway was sitting in my car and my car started rolling backwards. The car was off in gear with the E brake on. I videotaped this happening every 20 seconds the car with balance, and roll back an inch or two. After 4 1/2 minutes, the car rolled the rest of the way down my driveway until it hi… Look up ODI 11513648 at NHTSA ↗ | 2229.3%ODI 11608115The display screen freezes up disabling all functions.Including back up camera,A/C, and radio. Look up ODI 11608115 at NHTSA ↗ | 917.3%ODI 11666494Child safety locks on back left door do not lock allowing back seat passengers to open door freely and endangering everyone in vehicle. Look up ODI 11666494 at NHTSA ↗ | 112.5%ODI 11733774Summary of the Safety Problem: A 2026 Ford Bronco rolled out of its parked position with no occupants, despite being left in Park, and collided with another vehicle. Full Description of the Incident: The Ford Bronco was placed in Park, was not running, and had no occupants. I exited the vehicle several times to reinstall the removable roof panels. The vehicle remained stationary during this process. After completing the roof panel installation, my wife and I closed the doors and trunk and we walked toward the building. A witness (the owner of … Look up ODI 11733774 at NHTSA ↗ |
|---|
| Service Brakes | 198.3%ODI 11453655The 21 Bronco is sold and marketed as being set up and safe to flat tow recreationally. The problem is with the 2.7l engine which has an Electric Brake Booster. After 45 mins the Battery Management system turns the Electric Brake Booster off. Thus the brakes are not powered and the required by law, brake system (3rd party) can not apply enough pressure. This is a SERIOUS design flaw. I have reached out to FORD, they denied that there is a global problem and asked me to contact my dealer. The dealer search TSB's and other systems and saw … Look up ODI 11453655 at NHTSA ↗ | 4010.6%ODI 11455044Flat Towing 2021 Ford Bronco with 2.7 V6 engine. After connecting my Bronco to the motorhome and putting it in the tow mode the following will occur. About 45 mins after turning the ignition off and closing the doors the EBB (Electronic Brake Boost) in the Bronco shuts down leaving the Bronco without any brake boost and leaves the supplemental brake system ineffective. When first connecting the Bronco to the motorhome the brake boost is active and the supplemental bakes system must be set to match, or it will lock up the brakes on the Bronco wh… Look up ODI 11455044 at NHTSA ↗ | 167.1%ODI 11513648Emergency brake failure. I have a very slight slope on my driveway. My car rolled halfway down my driveway. I assumed I did something wrong although I knew I had the car in gear with the E brake on. Two hours later I came back from an errand parked on my driveway was sitting in my car and my car started rolling backwards. The car was off in gear with the E brake on. I videotaped this happening every 20 seconds the car with balance, and roll back an inch or two. After 4 1/2 minutes, the car rolled the rest of the way down my driveway until it hi… Look up ODI 11513648 at NHTSA ↗ | 79.3%ODI 11631438When the Vehicle is put into Neutral Tow Mode and Towed behind a vehicle while using a supplemental braking system. The Bronco's Brake system becomes intermittently Active. Causing the slightest pressure to lock up the brakes. The Same issue as reported in. SSM 51415 . The Bronco power brake system is supposed to be de activated once it is put into neutral tow mode. Thus you set the supplemental brake system to respond as a vacuum brake system. So when the brake system on the Bronco becomes active during a stop it will lock up the wheels on t… Look up ODI 11631438 at NHTSA ↗ | 713.5%ODI 11714693Loss of braking. Note weather was cold in single digits Fahrenheit and midly snowy. I drove my 2025 Ford Bronco that was purchased in Octorber about 20 minutes to drop off my child at daycare. Going into the daycare I turned to Slippery/4A mode. After about 5 minutes inside I pulled out and switched back to Normal/2H mode. Less than half a mile later I got multiple warnings that the brakes, EBB, collision detect, and ABS had faulted, and I should service now. I only had the electronic parking brake available. I was able to use it and engine bra… Look up ODI 11714693 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Power Train | 73.1%ODI 11465356Transmission broke at 4,884 miles reversing out of the driveway. The driveway has no grade and never sits on a hill. Look up ODI 11465356 at NHTSA ↗ | 3910.4%ODI 11463482Engine comes and goes, Wastegate gets stuck Look up ODI 11463482 at NHTSA ↗ | 219.3%ODI 11507718Within the first 500 miles on my brand new bronco, I noticed a strange burning smell after driving it one day. The next morning when I started it, I heard what I thought was a heat shield rattle, and as I continued to drive my bronco to work throughout the week the noise got worse. Last weekend my wife and I went on a 400 mile trip and the noise was so bad when we returned I scheduled an appointment with the dealership this week. They apparently opened up the transmission today and found metal shavings and a broken case piece so they determined… Look up ODI 11507718 at NHTSA ↗ | 68.0%ODI 11582872I was driving down the road and the front end of the car started to shake. The power to the car then went out. The message on the dash said to put it in park and restart so I did. I was able to get it started, and put it in drive and then it shook again and the power went out. The message on my Ford App said that there were two issues with the transmission. One was a transmission shift solenoid not responding and the other message was that the transmission clutch did not apply within the time as expected resulting in delayed or hard shifts… Look up ODI 11582872 at NHTSA ↗ | 59.6%ODI 116794702025 Bronco Sport Safety Recalls* Replace instrument panel cluster Recall incomplete Block heater element replacement Recall incomplete Cylinder head replacement Recall incomplete Cylinder head inspectionreplacement Recall incomplete DO NOT DRIVE! RECOMMENDED TO REPORT NATIONAL ALERT FOR OWNERS OF THIS VEHICLE TYPE. INVESTOR REPORTING FOR BROADCAST RECALL ALERT! Look up ODI 11679470 at NHTSA ↗ | 112.5%ODI 11750827 · 617 miThe contact owns a 2026 Ford Bronco. The contact stated that while driving at approximately 10 MPH and depressing the accelerator to make a left turn, the vehicle failed to accelerate as intended. The transmission shifted into neutral, and the vehicle coasted forward. The contact pulled over to the side of the road and activated the hazard lights. The system was reset, and the vehicle was able to accelerate. There were no warning lights illuminated. The vehicle was taken to the dealer, who was unable to duplicate or determine the cause of the f… Look up ODI 11750827 at NHTSA ↗ |
|---|
| Suspension | 2310.0%ODI 11484049 · 9 miThe contact owns a 2021 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle was lopsided due to the driver's side front suspension measuring 38.25 inches from the ground while the passenger's side rear suspension measured 40.5 inches from the ground. The contact was concerned that in the event of a tire blowout, the weight distribution would cause a rollover. The vehicle was taken to the dealer where it was diagnosed with a faulty suspension that needed to be replaced. The dealer informed the contact that the… Look up ODI 11484049 at NHTSA ↗ | 277.2%ODI 11503206On January 17, 2023, while driving down a commonly driven road (Muldoon) in Anchorage, Alaska at approximately 30 mph, I suddenly heard a large air escaping noise "Psh Psh Psh Psh" and it took me a moment to realize what was happening--the dash indicated the PSI of my rear driver's-side tire was deflating rapidly, to completely flat. Had the vehicle lost control in these snowy conditions, it could have ran into multiple other cars on the road--not ruling out the possibility of a roll-over type accident. When I pulled over into a parking lot, I… Look up ODI 11503206 at NHTSA ↗ | 135.8%ODI 11521052We have had two major issues with this new Vehicle. It has less 1,872 miles on it and it is only about 2 months old. Within a week of owning it, the stabilizer bar went out and render the vehicle un drive able. We have a second issue that is even larger safety issue. The Vehicle is now dying and leaving you stranded on the side of the road. We have now had this happened to us three times on separate occasions. Once was on a trip back from Oklahoma to Dallas and the highway is under repair/construction and there are miles that there are o… Look up ODI 11521052 at NHTSA ↗ | 56.7%ODI 11651598Dealer sold us a brand new vehicle with an active recall. Recall# 25S01/25V025 which was released January 21st, 2025. We bought the vehicle [XXX]. There was ample time for the dealer to pull these vehicles from the lot and prevent them from being sold. I spoke with a Ford customer service representative (case# [XXX]) and was told this dealer sold several vehicles with this recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) Look up ODI 11651598 at NHTSA ↗ | 23.8%ODI 11730482Description: My 2025 Ford Bronco suffered a catastrophic failure of both rear shock absorver external reservoirs, consistent with Recall 25S01 (NHTSA 25V025). The reservoirs detached intirely while driving out-of-state, forcing an 800-mile transit with 5 passengers on an unstable suspension. Issue: Upon presenting the vehicle to Interstate Ford, the dealer and a Ford Representative issued a formal denial of warranty coverage. They cited Claim Type 14, Condition Code 39 ("Missing Part"). Why it's a Safet Risk: Ford is using the severity of t… Look up ODI 11730482 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|
| Fuel/Propulsion System | 229.6%ODI 11470405On June 9, 2022, while traveling on an Interstate Highway at about 80 mph, the engine sputtered and died without any warning light activation. The vehicle failure caused an extremely unsafe condition which caused me to navigate without power, in moderate traffic, from the #1 lane, across the #2 lane and onto the shoulder. The failure caused me to perform this high risk maneuver in front of an approaching big rig traveling in the #2 lane. The vehicle was towed to the nearest Ford dealership where an inspection determined the fuel pump had fai… Look up ODI 11470405 at NHTSA ↗ | 369.6%ODI 11482719In remote area in a canyon the engine quit suddenly due to fuel starvation caused by faulty fuel pump. The engine quit on the edge of the cliff and would not start again. Check Engine light was illuminated. After being towed to the nearest dealership. I was advised that my Bronco needs a new Fuel Pump. Vehicle warnings are as follows: - Electrical Fault with the Fuel Pump. - Engine Fuel Control System cannot achieve required fuel pressure to start engine. - Engine Fuel Control Sytem is unable to control fuel system pressure. Look up ODI 11482719 at NHTSA ↗ | 31.3%ODI 11576255While driving the vehicle began to misfire and became unsafe to drive. It was towed to the local dealer where error codes confirmed that cylinder 4 had misfired. Ford was unable to duplicate the issue nor where they able to find any issues that would have caused the misfire after trouble shooting. Look up ODI 11576255 at NHTSA ↗ | 22.7%ODI 11624335There is an issue when I try to pump gas the pump repeatedly kicks off. It happens every time I put gas in my vehicle. It causes me to not know when the fuel is full. It’s not an issue with the gas pump because it happens at all different locations. It’s a problem with the vehicle itself. Look up ODI 11624335 at NHTSA ↗ | 11.9%ODI 11685755I was driving the vehicle on high mountain pass roads in Colorado. Anytime I would approach approximately 11,400 feet of elevation. The vehicle would instantly lose all power with no warning lights of any kind. All gauges were in the normal operating range. Vehicle would barely move 2 mph. Created a very unsafe condition on narrow steep dirt roads in the mountains. As soon as I turned around and descended approximately 100 feet in elevation the power came back instantly and vehicle operated normally. This happened on three occasions. The roads … Look up ODI 11685755 at NHTSA ↗ | 00.0%No examples available for this selection. |
|---|