Jayco REDHAWK problems and owner complaints

I was driving slowly looking for an open gas station on a highwsy in Va. i attempted to make a left hand turn when i heard a snapping sound. I then had a complete loss of power steering and braking capacity. I started rolling across the highway mashing the brakes and finally put my Ebrake on stopping my RV. There were not any lights lit up on the dashboard before or after this incident. If i was going 70 down a busy highway, the outcome of this incident would be much different. My children would be planning my funeral today.

Look up ODI 11452684 at NHTSA ↗

We received the two recall notice letters from Ford Motor Company, 20V795 & 22V089, for our 2021 Jayco Redhawk class C RV. Upon receiving the first recall notice, 20V795, an appointment was made with our local Ford Dealer, Spradley Ford Lincoln Mercury, in Pueblo, CO, on Oct 1, 2021 to have it inspected and recall taken care of. Upon arrival that morning, was told they did not have the parts, would have to order them & their technician just called in "sick". Appointment was rescheduled once they had the recall parts in for Nov 15, 2021, agai…

Look up ODI 11460299 at NHTSA ↗

SINCE THE PURCHASE OF THIS CLASS C RV I HAVE NOTICED CRACKS FORMING ON THREE OCCASIONS ON THE OUTSIDE FIBERGLASS OF THE OVER CAB AREA. THE CRACKS FORMED ON TOP CLOSE TO THE EDGE OF THE CAB ON BOTH SIDES AROUND HALFWAY FROM THE ROOF LINE AND THE CURVED AREA. INSTEAD OF SOME RANDOM FIBERGLASS CRACKS THIS CRACKS APPEAR TO ME MORE OF A STRESS RELATED PROBLEM OR SOME TYPE OF STRUCTURAL DEFECT IN DESIGN AS THEY APPEARED DIRECTLY ACROSS FROM EACH OTHER ON BOTH SIDES OF THE CAB AND RE-APPEAR AFTER REPAIRS. THE FIRST CRACKS WERE NOTED IN FEB 2015 ON THE…

Look up ODI 10816239 at NHTSA ↗

TL* THE CONTACT OWNS A 2018 (NA) JAYCO REDHAWK XD. WHILE THE VEHICLE WAS STATIONARY, THE CONTACT NOTICED A HOLE UNDER THE SOFA BED THAT EXPOSED THE MOTOR HOME'S BUILT-IN GENERATOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 1,000.

Look up ODI 10981240 at NHTSA ↗

WE HAVE RECEIVED 3 RECALL NOTICES PERTAINING TO THE SHOWER ENCLOSURE IN OUR MOTORHOME. WE HAVE ATTEMPTED TO HAVE THE REPAIR MADE BY 2 DIFFERENT LOCAL DEALERS & HAVE BEEN UNSUCCESSFUL. WE CONTACTED THE CUSTOMER SERVICE DEPT. AT JAYCO & RECEIVED NO HELP. THIS IS A SAFETY RECALL (#16V-568) THAT DOESN'T SEEM IMPORTANT ENOUGH TO OUR LOCAL JAYCO DEALERSHIPS TO ADDRESS. WE ALSO SENT A DETAILED LETTER TO JAYCO'S REGULATORY COMPLIANCE DIVISION, AND RECEIVED NO RESPONSE. YESTERDAY WE RECEIVED ATECHNICAL SERVICE BULLETIN NOTIFICATION TSB #19-022 PERTAININ…

Look up ODI 11232269 at NHTSA ↗

Description of the Incident: While driving our RV on the expressway, the slide-out unexpectedly extended on its own without anyone pressing the control button or getting up from their seat. The slide-out extended several feet outward while the vehicle was moving at highway speed. Component/System that Failed: The slide-out mechanism/control system malfunctioned. It appears to have activated spontaneously. The component is available for inspection upon request. Safety Risk: This malfunction created an extreme safety hazard. The slide-out expande…

Look up ODI 11697353 at NHTSA ↗

THE SRS WARNING LIGHT REMAINED ON CONSTANTLY. HAD IT REPAIRED AT 4984 MILES. FORD REPAIR FACILITY FOUND CHAFFED/FRAYED WIRING WHERE UNPROTECTED WIRES WERE ROUTED BY THE COACH MANUFACTURER THROUGH OR NEAR AN ALUMINUM PANEL TO THE LEFT OF THE DRIVERS SEAT . REPAIR REPORT AND PHOTO ARE AVAILABLE. THIS CAUSED THE FAILURE OF THE SRS. NO INJURY OR ACCIDENT OCCURRED BUT THE POSSIBILITY OF FIRE AND NO AIRBAG IN A CRASH COULD HAVE RESULTED. *TR

Look up ODI 10714900 at NHTSA ↗

TL* THE CONTACT OWNS A 2019 JAYCO REDHAWK. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH THE ODOR OF BURNING SMOKE WAS PRESENT. AFTER STOPPING TO INSPECT THE VEHICLE IT WAS DISCOVERED THE INCANDESCENT LIGHT BULB IN THE STORAGE UNIT HAD OVERHEATED CAUSING DAMAGE TO THE LIGHT COVER AND ITEMS INSIDE THE STORAGE UNIT. THE CONTACT INDICATED THAT THE FAILURE WAS DUE TO ITEMS MOVING INSIDE THE STORAGE SPACE MAKING CONTACT WITH THE LIGHT BULB. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE LOCAL DEALER WAS NOT NOTIFIED. THE FAILURE MILE…

Look up ODI 11348558 at NHTSA ↗

Description of the Incident: While driving our RV on the expressway, the slide-out unexpectedly extended on its own without anyone pressing the control button or getting up from their seat. The slide-out extended several feet outward while the vehicle was moving at highway speed. Component/System that Failed: The slide-out mechanism/control system malfunctioned. It appears to have activated spontaneously. The component is available for inspection upon request. Safety Risk: This malfunction created an extreme safety hazard. The slide-out expande…

Look up ODI 11697353 at NHTSA ↗

I was driving slowly looking for an open gas station on a highwsy in Va. i attempted to make a left hand turn when i heard a snapping sound. I then had a complete loss of power steering and braking capacity. I started rolling across the highway mashing the brakes and finally put my Ebrake on stopping my RV. There were not any lights lit up on the dashboard before or after this incident. If i was going 70 down a busy highway, the outcome of this incident would be much different. My children would be planning my funeral today.

Look up ODI 11452684 at NHTSA ↗