2016 Mercedes-Benz E63 problems and owner complaints

THERE IS A FUEL SMELL COMING FROM THE REAR OF THE CAR. I REMOVE THE REAR SEAT AND VERIFIED THE FUEL SENDING UNIT IS LEAKING. THERE WAS PUDDLE OF GAS AROUND THE SENDING UNIT. ESPECIALLY AFTER FILLING THE GAS TANK WITH FUEL, THE SMELL IS MUCH STRONGER. OTHER PEOPLE HAVE PASSED BY MY CAR WHILE IT IS PARKED AND HAVE TOLD ME THEY SMALL GAS. I HAD THE CAR SERVICED AT MERCEDES OF GILBERT IN ARIZONA. THEY VERIFIED THE FUEL SENDING UNIT ON THE DRIVER'S SIDE IS LEAKING GAS. THEY WANT SOMETHING LIKE $1,350 FOR THE REPAIRS. MY PREVIOUS CAR WAS A 20…

Look up ODI 11053954 at NHTSA ↗

Strong smell of gas noted at the driver rear wheel well after a fillup. Under the rear seat, the top of the fuel tank is under a pool of gasoline. The cap that covers pump/filter/sending units is leaking. I cleaned up the gasoline, and almost immediately the indent on the top of the tank began filling up with gasoline again. Air is getting into the fuel system, making it difficult to start. No warning lights to indicate an issue.

Look up ODI 11425833 at NHTSA ↗

TL* THE CONTACT OWNS A 2012 MERCEDES-BENZ E63. WHILE THE VEHICLE WAS PARKED OR WHILE DRIVING, A FUEL ODOR WAS PRESENT INSIDE AND OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO MERCEDES-BENZ OF CHANDLER (LOCATED AT 7450 W ORCHID LN, CHANDLER, AZ 85226, [phone removed]) WHERE IT WAS DIAGNOSED THAT A CRACK IN THE FUEL SENDING UNIT ON THE FUEL TANK AND THE SENDING UNIT ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS OUT OF …

Look up ODI 11142269 at NHTSA ↗

TAKATA RECAL MERCEDES NEVER CONTACTED ME AGAIN FOR A REPLACEMENT. IT HAS BEEN HALF A YEAR SINCE I RECEIVED THE NOTIFICATION OF THIS RECALL. REMEDY NOT READY IS ALWAYS THE EXCUSE.

Look up ODI 10945169 at NHTSA ↗

TL* THE CONTACT OWNS A 2015 MERCEDES-BENZ E63 EQUIPPED WITH DISTRONIC PLUS ACTIVE CRUISE CONTROL AND PRE-SAFE BRAKING. WHILE DRIVING 55, MPH THE CONTACT'S VEHICLE CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT STATED THAT THE PRE-SAFE BRAKING SYSTEM AND THE ACTIVE CRUISE CONTROL FAILED TO OPERATE AS INTENDED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEA…

Look up ODI 10888970 at NHTSA ↗

Brake pedal went to floor and brake function became significantly impaired and dangerous. Took car to local shop who diagnosed as failed rear brake lines, and most of the entire length of the rear lines were in very bad condition. Car only has 104k on it. It doesn't take much searching on the internet to see how widespread of a problem this is, and even the dealer admits they do multiple of these per week on the W212 (and a few other platforms are affected). The front lines seem to be in good shape so there does seem to be a design issue he…

Look up ODI 11593191 at NHTSA ↗

TL* THE CONTACT OWNS A 2015 MERCEDES-BENZ E63 EQUIPPED WITH DISTRONIC PLUS ACTIVE CRUISE CONTROL AND PRE-SAFE BRAKING. WHILE DRIVING 55, MPH THE CONTACT'S VEHICLE CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT STATED THAT THE PRE-SAFE BRAKING SYSTEM AND THE ACTIVE CRUISE CONTROL FAILED TO OPERATE AS INTENDED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEA…

Look up ODI 10888970 at NHTSA ↗

VEHICLE SENSORS RELATING TO STEERING AND TIRES PROVIDED INCORRECT AND DANGEROUS INFORMATION THAT ADVERSELY AFFECTED THE STEERING CONTROL OF THE VEHICLE, WHICH RESULTED IN THE VEHICLE DEPARTING A SUBURBAN, RESIDENTIAL ROADWAY WHILE IN MOTION, STRIKING A TREE AND KILLING THE DRIVER AND INJURING TWO PASSENGERS.

Look up ODI 10893613 at NHTSA ↗

VEHICLE SENSORS RELATING TO STEERING AND TIRES PROVIDED INCORRECT AND DANGEROUS INFORMATION THAT ADVERSELY AFFECTED THE STEERING CONTROL OF THE VEHICLE, WHICH RESULTED IN THE VEHICLE DEPARTING A SUBURBAN, RESIDENTIAL ROADWAY WHILE IN MOTION, STRIKING A TREE AND KILLING THE DRIVER AND INJURING TWO PASSENGERS.

Look up ODI 10893613 at NHTSA ↗

I WAS DRIVING HOME AFTER WORK DURING RUSH HOUR TRAFFIC ONE AFTERNOON AND ALL OF A SUDDEN I HEARD A LOUD BANG I PULLED OVER TO SEE IF A ROCK OR ROAD DEBRIS HAD HIT MY CAR. I COULD NOT FIND ANY SIGNS OF IMPACT. LATER ON I NOTICED THAT THE PANORAMIC ROOF SECTION BETWEEN THE WINDSHIELD AND SUNROOF HAD SHATTERED THERE ARE NO SIGNS OF IMPACT NO ROCK CHIPS, NOTHING.

Look up ODI 11204889 at NHTSA ↗

TL* THE CONTACT OWNS A 2015 MERCEDES-BENZ E63 EQUIPPED WITH DISTRONIC PLUS ACTIVE CRUISE CONTROL AND PRE-SAFE BRAKING. WHILE DRIVING 55, MPH THE CONTACT'S VEHICLE CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT STATED THAT THE PRE-SAFE BRAKING SYSTEM AND THE ACTIVE CRUISE CONTROL FAILED TO OPERATE AS INTENDED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEA…

Look up ODI 10888970 at NHTSA ↗

I WAS DRIVING HOME AFTER WORK DURING RUSH HOUR TRAFFIC ONE AFTERNOON AND ALL OF A SUDDEN I HEARD A LOUD BANG I PULLED OVER TO SEE IF A ROCK OR ROAD DEBRIS HAD HIT MY CAR. I COULD NOT FIND ANY SIGNS OF IMPACT. LATER ON I NOTICED THAT THE PANORAMIC ROOF SECTION BETWEEN THE WINDSHIELD AND SUNROOF HAD SHATTERED THERE ARE NO SIGNS OF IMPACT NO ROCK CHIPS, NOTHING.

Look up ODI 11204889 at NHTSA ↗