2023 Gillig LOW FLOOR: complaints, problems and recalls
Explore the records behind recurring owner reports.
Key facts
0 owner complaints analyzed
15 distinct recall campaigns
Not available median reported failure mileage
Scope: 2023 model year. Data updated: . 0 complaints include usable failure mileage. View data status.
Most common problems
No owner complaints are recorded for this selection. A complaint can name multiple components.
Component breakdown
Number of unique complaints naming each component. Top eight shown.
No usable records for this chart.
| Category | Count |
|---|
No records.
Reported problems by failure mileage
Complaint counts in mileage bands. These are not failure rates per vehicle or mile.
| Category | Count |
|---|---|
| Under 25,000 | 0 |
| 25,000 to 49,999 | 0 |
| 50,000 to 74,999 | 0 |
| 75,000 to 99,999 | 0 |
| 100,000 to 149,999 | 0 |
| 150,000 and above | 0 |
Under 25,000: 0; 25,000 to 49,999: 0; 50,000 to 74,999: 0; 75,000 to 99,999: 0; 100,000 to 149,999: 0; 150,000 and above: 0
No usable failure mileage is recorded. 0 complaints have missing, zero or invalid mileage.
Complaints over time
Year the complaint was filed, not the vehicle model year or incident year. The snapshot year is partial.
No usable records for this chart.
| Category | Count |
|---|
No records.
Pattern summary
There is not enough complaint evidence to summarize patterns.
Calculated from recorded counts. An AI narrative has not been published for this selection.
Examples from the source records
Examples provide context, not a representative sample or a verified diagnosis.
Recall history
15 distinct campaigns affect this selection. Announcement dates below are different from vehicle model years. A campaign may cover multiple years.
23V075000 · Steering:Linkages:Drag:Link:Connection
Reported: 2023-02-10 (February 10, 2023)
Gillig, LLC (Gillig) is recalling certain 2022-2023 Low Floor transit and shuttle buses. Incompatible steering system draglink parts may have been installed during the vehicle assembly process, potentially resulting in long-term damage of the steering system.
Consequence: A damaged steering system can result in a loss of vehicle handling and control, increasing the risk of a crash.
Remedy: Gillig will inspect and, when necessary, replace and tighten the draglink rod, free of charge. Owner notification letters were mailed March 29, 2023. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
NHTSA campaign record ↗23V635000 · Power Train:Driveline:Driveshaft
Reported: 2023-09-14 (September 14, 2023)
Gillig, LLC (Gillig) is recalling certain 2022-2023 Low Floor transit buses. The driveshaft fasteners may have been improperly tightened after service repairs, allowing the driveshaft to detach.
Consequence: A detached driveshaft can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Gillig will replace the driveshaft straps and fasteners, free of charge. Owner notification letters were mailed October 9, 2023. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
NHTSA campaign record ↗23V740000 · Power Train:Driveline:Driveshaft
Reported: 2023-11-03 (November 3, 2023)
Gillig, LLC (Gillig) is recalling certain 2019-2023 Low Floor transit buses. The transmission yoke may separate, resulting in driveshaft separation and a sudden loss of drive power.
Consequence: A sudden loss of drive power can increase the risk of a crash. Additionally, a disabled bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury to passengers.
Remedy: Gillig will work with the equipment manufacturer, Allison Transmission Inc., to inspect and tighten the transmission yoke bolts, as necessary, free of charge. Owner notification letters were mailed December 11, 2023. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
NHTSA campaign record ↗23V809000 · Power Train:Axle Hubs
Reported: 2023-12-04 (December 4, 2023)
Gillig, LLC (Gillig) is recalling certain 2023 Low Floor vehicles. An inadequate amount of lubricant in the rear axle hubs may cause failure of the rear drive axles.
Consequence: Rear drive axle failure can result in a loss of vehicle control and increase the risk of a crash or injury.
Remedy: Gillig will inspect for correct rear axle hub lubricant levels and add lubricant and gear oil as necessary, free of charge. Owner notification letters were mailed January 12, 2023. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
NHTSA campaign record ↗23V812000 · Visibility:Rearview Mirrors/Devices | Electrical System:Wiring:Fuses And Circuit Breakers
Reported: 2023-12-04 (December 4, 2023)
Gillig, LLC (Gillig) is recalling certain 2021-2023 Low Floor vehicles. The rearview mirror electric adjustment system may have been manufactured with an incorrect fuse.
Consequence: An incorrect fuse may overheat and increase the risk of a fire.
Remedy: Gillig will replace the protection fuse of the mirror control switch, free of charge. Owner notification letters were mailed January 15, 2024. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
NHTSA campaign record ↗24V390000 · Fuel System, Diesel:Delivery:Hoses, Lines/Piping, And Fittings
Reported: 2024-06-03 (June 3, 2024)
Gillig, LLC (Gillig) is recalling certain 2023 Low Floor buses equipped with Cummins L9 diesel engines with part number D563027BX03. Insufficient crimping may allow the remote fuel filter hoses to disconnect and leak, decreasing fuel supply to the engine.
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire. Additionally, a lack of fuel can cause an engine stall, increasing the risk of a crash.
Remedy: Cummins will replace the remote fuel filter hoses. Owner notification letters were mailed June 21, 2024. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
NHTSA campaign record ↗24V514000 · Steering:Critical Fasteners
Reported: 2024-07-05 (July 5, 2024)
Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor transit buses. The steering spline shaft fasteners may have been improperly tightened, allowing the steering spline shaft to loosen.
Consequence: A loose steering shaft can cause a complete loss of steering control, increasing the risk of a crash.
Remedy: Gillig will tighten the fasteners, free of charge. Owner notification letters were mailed August 13, 2024. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.
NHTSA campaign record ↗24V921000 · Electrical System:Instrument Panel:Speedometer/Odometer
Reported: 2024-12-11 (December 11, 2024)
Gillig, LLC (Gillig) is recalling certain 2023 Low Floor diesel-hybrid transit buses. During vehicle operations in full electric vehicle (EV) mode, the odometer will not display accumulated mileage. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."
Consequence: A missing odometer reading could lead to an unintended delay in critical safety-related maintenance, potentially impairing the safe operation of the vehicle and increasing the risk of a crash.
Remedy: Gillig will install a new speedometer gauge, free of charge. Owner notification letters were mailed December 20, 2024. Owners may contact Gillig customer service at 1-800-735-1500 or 1-510-264-5073.
NHTSA campaign record ↗24V958000 · Equipment:Emergency:Fire Supression:Wiring | Electrical System:Wiring:Relays/Solenoids
Reported: 2024-12-20 (December 20, 2024)
Gillig, LLC (Gillig) is recalling certain 2021-2024 Low Floor style transit buses. The fire suppression relay cable may be damaged, chafing against the mounting bolt, and fail.
Consequence: Failure of the fire suppression system can increase the risk of injury during a fire.
Remedy: Dealers will replace the relay cable, free of charge. Owner notification letters were mailed December 31, 2024. Owners may contact GILLIG customer service at 1-800-735-1500.
NHTSA campaign record ↗24V959000 · Electrical System:Ignition:Interlock/Lockout
Reported: 2024-12-20 (December 20, 2024)
Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor style transit buses. The high voltage electric air compressor may not be connected to the High Voltage Interlock Loop (HVIL). Therefore, the HVIL cannot detect a loose or disconnected compressor power cable.
Consequence: Failure to alert the operator to a power cable issue can increase the risk of injury by electrical shock.
Remedy: Dealers will install an additional electrical harness, extending the HVIL loop to the air compressor, free of charge. Owner notification letters were mailed February 12, 2025. Owners may contact GILLIG customer service at 1-800-735-1500.
NHTSA campaign record ↗25V076000 · Equipment:Appliance:Tv/Radio/Speakers
Reported: 2025-02-11 (February 11, 2025)
Gillig, LLC (Gillig) is recalling certain 2019-2024 Low Floor transit buses. The rivet-nut fasteners that secure the TFT flat panel display monitor to the bus ceiling may fail, causing the monitor to detach and fall.
Consequence: A monitor that detaches and falls from the ceiling increases the risk of injury.
Remedy: Gillig will replace the rivet-nut fasteners, free of charge. Owner notification letters were mailed March 18, 2025. Owners may contact Gillig customer service at 1-800-735-1500.
NHTSA campaign record ↗25V203000 · Electrical System:Propulsion System:Traction Battery
Reported: 2025-04-01 (April 1, 2025)
Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor transit buses. The high voltage batteries may have loose hardware that can fall inside the battery pack and create a short circuit.
Consequence: A short circuit increases the risk of a fire. In addition, the battery contactors may open suddenly and cause a loss of drive power, increasing the risk of a crash.
Remedy: Gillig will install new battery fasteners as necessary, free of charge. Owner notification letters were mailed April 28, 2025. Owners may contact Gillig customer service at 1-800-735-1500.
NHTSA campaign record ↗26V142000 · Fuel System, Diesel:Delivery:Hoses, Lines/Piping, And Fittings
Reported: 2026-03-12 (March 12, 2026)
Gillig, LLC (Gillig) is recalling certain 2021-2026 Low Floor transit buses. The air compressor intake pipe may contact and damage the fuel line.
Consequence: A damaged fuel line may leak, increasing the risk of a fire.
Remedy: Gillig will inspect, replace, and reorient the intake pipe as necessary, free of charge. Owner notification letters were mailed April 24, 2026. Owners may contact Gillig's customer service at 1-800-735-1500.
NHTSA campaign record ↗26V144000 · Electrical System:Propulsion System: Cables
Reported: 2026-03-12 (March 12, 2026)
Gillig, LLC (Gillig) is recalling certain 2023-2026 Low Floor transit buses. The high voltage cable, connecting the inverter to the drive unit, contains a splice connection that reduces the amp capacity rating.
Consequence: Reduced capacity may cause the cable to overheat, increasing the risk of a fire.
Remedy: Gillig will reprogram the software as an interim repair. For the final remedy, Gillig will replace the high voltage cable. Both repairs will be provided free of charge. Owner notification letters are expected to be mailed July 27, 2026. Owners may contact Gillig's customer service at 1-800-735-1500.
NHTSA campaign record ↗26V190000 · Equipment:Other:Labels
Reported: 2026-03-26 (March 26, 2026)
Gillig, LLC (Gillig) is recalling certain 2023-2024 Low Floor transit buses equipped with Michelin X InCity Grip D rear tires. The rear Gross Axle Weight Rating (GAWR) on the federal placard may exceed the tire load rating. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 120, "Wheels and Rims - Other Than Passenger Cars."
Consequence: Referencing an incorrect GAWR can lead to unintentionally overloading the rear tires, increasing the risk of a crash.
Remedy: Gillig will replace the federal placard, free of charge. Owner notification letters are expected to be mailed April 24, 2026. Owners may contact Gillig customer service at 1-800-735-1500.
NHTSA campaign record ↗Vehicle analysis explorer
Inspect model-year patterns, reported mileage, monthly activity and the evidence behind each signal.
Data completeness
0 unique complaints in this selection. Analysis snapshot: 2026-10-01.
Missing, zero and invalid mileage is excluded. Dates after the snapshot are excluded. Examples are limited selections, not a representative sample.
Problems by model year
Model-wide comparison of the eight most reported components across the model. Cells show counts and shares within each model year. Open a cell for source examples.
| Component | 2012 | 2013 | 2014 | 2015 | 2016 | 2017 | 2018 | 2019 | 2020 | 2021 | 2022 | 2023 | 2024 | 2025 | 2026 |
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| Electrical System | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 1100.0%ODI 11418027We have approximately 495 buses that we found out can be started even though the battery disconnect switch is in the "disconnected" position. It will start and run for several minutes until the super capacitor is drained. This is hazardous to maintenance personnel who disconnect the batteries to work on the vehicle, then someone else may start it while that other person is in a dangerous position in the engine compartment. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. |
| Tires | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 1100.0%ODI 10970574MICHELIN 305/85R22.5 XZU3 (J) SAME FAILURES THAT CAUSED THE VOLUNTARY RECALL OF 2012. ALL REMAINING PRODUCTION DATES AFTER THE RECALL (2011-WEEK 45 AND FORWARD). BEAD PLY SEPARATION AFTER 100,000 MILES. TIRES ARE BLOWING OUT FROM THE BEAD ON BUSES. MICHELIN REPRESENTATIVES HAVE ACKNOWLEDGED THAT THERE IS A PROBLEM AND INSTRUCTED US TO REMOVE ALL 2011 (POST RECALL) /2012 / 2013 TIRES FROM FLEET. THIS IS DEFINITELY A SAFETY ISSUE. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. |
| Engine | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 1100.0%ODI 11418027We have approximately 495 buses that we found out can be started even though the battery disconnect switch is in the "disconnected" position. It will start and run for several minutes until the super capacitor is drained. This is hazardous to maintenance personnel who disconnect the batteries to work on the vehicle, then someone else may start it while that other person is in a dangerous position in the engine compartment. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. |
| Exterior Lighting:Turn Signal | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. |
| Seat Belts | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 1100.0%ODI 11254141 · 3,100 miI DRIVE BUSES FOR DISNEY WORLD AND THEY HAVE JUST GOT SOME NEW BUSES WITH NEW SEATS AND TWO PART SEAT BELTS. THE WAY THE LAP BELT AND SHOULDER BELT HOOK TOGETHER CAUSE THEM TO TWIST WHICH ALLOWS THE SHOULDER BELT TO JAM IN THE RETURN GUIDE NOT ALLOWING THE BELT TO FULLY RETRACT AND HOLD PROPERLY.I HAVE BEEN WRITTEN UP FOR NOT WEARING MY BELT PROPERLY BUT THIS IS A BELT ISSUE AND A MAJOR SAFETY CONCERN IF THE BELT WILL NOT FULLY RETRACT IT WILL NOT FULLY OPERATE IN A COLLISION. I HAVE SHOWED THIS TO A MANAGER AND ANOTHER WROTE ME UP FOR NOT WEAR… | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. |
| Service Brakes | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 00.0%No examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 0UnavailableNo examples available for this selection. | 1100.0%ODI 11759345This complaint involves Gillig all-electric transit buses, model years 2024–2026, and a recurring failure of the electric air compressor supplying the air brake system. When the compressor fails, system air pressure drops, resulting in automatic application of the brakes. Unlike a conventional combustion-engine drivetrain, the all-electric drivetrain can continue producing sufficient torque to allow the driver to power through the automatically applied brakes, particularly when the low-air condition occurs while the bus is in motion. This con… |
Darker cells indicate a larger share of submitted complaints. Components overlap. This measures complaint composition, not failure probability.
Failure mileage by component
Median and middle 50% of usable owner-reported mileages. Ranges require at least five records.
| Component | Mileage range (25th–75th percentile) | Median | Usable records | Examples |
|---|---|---|---|---|
| No usable records for this analysis. | ||||
Complaint and recall timeline
Explore monthly filing activity alongside recall announcements. Up to ten years of monthly history is available.
Solid line: filed complaints. Dashed amber lines: recall announcement dates for this vehicle selection; markers include all recall components. The latest month is partial. Temporal proximity does not establish causation.
Monthly counts, recall campaigns and complaint examples
| Month | Complaints | Campaigns announced | Examples |
|---|---|---|---|
| 2024-11 | 0 | None | No examples available for this selection. |
| 2024-12 | 0 | 24V921000, 24V958000, 24V959000 | No examples available for this selection. |
| 2025-01 | 0 | None | No examples available for this selection. |
| 2025-02 | 0 | 25V076000 | No examples available for this selection. |
| 2025-03 | 0 | None | No examples available for this selection. |
| 2025-04 | 0 | 25V203000 | No examples available for this selection. |
| 2025-05 | 0 | None | No examples available for this selection. |
| 2025-06 | 0 | None | No examples available for this selection. |
| 2025-07 | 0 | None | No examples available for this selection. |
| 2025-08 | 0 | None | No examples available for this selection. |
| 2025-09 | 0 | None | No examples available for this selection. |
| 2025-10 | 0 | None | No examples available for this selection. |
| 2025-11 | 0 | None | No examples available for this selection. |
| 2025-12 | 0 | None | No examples available for this selection. |
| 2026-01 | 0 | None | No examples available for this selection. |
| 2026-02 | 0 | None | No examples available for this selection. |
| 2026-03 | 0 | 26V142000, 26V144000, 26V190000 | No examples available for this selection. |
| 2026-04 | 0 | None | No examples available for this selection. |
| 2026-05 | 0 | None | No examples available for this selection. |
| 2026-06 | 0 | None | No examples available for this selection. |
| 2026-07 | 0 | None | No examples available for this selection. |
| 2026-08 | 0 | None | No examples available for this selection. |
| 2026-09 | 0 | None | No examples available for this selection. |
| 2026-10 (partial) | 0 | None | No examples available for this selection. |
Emerging complaint spikes
Complete months in the latest six months with at least 10 complaints, at least twice the preceding 12-month average, and at least three square-root deviations above that average.
This is a descriptive screening rule, not a statistical defect finding. Publicity and reporting changes can increase submissions.
No complete months meet the spike thresholds for this selection.
Equal-age model-year comparison
Model-wide cumulative reports during the first three or five calendar years, starting with the model year (age 0). Only fully elapsed windows are compared.
2022: 0 complaints · 2023: 0 complaints
| Model year | Through age 0 | Through age 1 | Through age 2 |
|---|---|---|---|
| 2022 | 0 | 0 | 0 |
| 2023 | 0 | 0 | 0 |
Date coverage across each selected cohort
| Year | Incident dates used | Filing date fallbacks | Excluded dates |
|---|---|---|---|
| 2022 | 0 | 0 | 0 |
| 2023 | 0 | 0 | 0 |
Incident date is preferred when valid and no later than filing; otherwise filing date is used. Model year approximates age. Equal observation time does not adjust for sales, distance driven or reporting delays. One complaint linked to multiple model years can appear in each cohort.
Components reported together
Each cell counts unique complaints naming both components. Open a nonzero cell for examples.
| Component |
|---|
| No usable records for this analysis. |
Co-reporting does not establish that one component caused another concern.
Recurring narrative patterns
Specific keyword mentions beyond broad component labels. Matching includes negations and comparisons and does not confirm a diagnosis.
0 patterns with matching reports.
No narratives match the published patterns.