Newmar CANYON STAR problems and owner complaints

I have a 2015 Newmar Canyon Star 3953 (on an F-53 Motorhome Chassis) serial number [XXX] with 57,335 miles. The attached picture does not do justice to what I have to say. The picture is the front rotor of the brake assembly. In between the outer and inner plates of the rotor are two steel rods. The only purpose (that is thought) of the rod is to balance the rotor. The problem is, the rotor heats up as you brake then expands the rotor which loosens the area around the rod. Centrifugal force moves the rod out of the air gap and it starts to hit…

Look up ODI 11454972 at NHTSA ↗

SHORTLY AFTER PURCHASING A 2016 NEWMAR CANYON STAR MOTORHOME, WE EXPERIENCED THE EMERGENCY BRAKE AND HYDROBOOST LIGHTS COMING ON. THIS WOULD RANDOMLY OCCUR WHETHER WE DROVE IT 30 FEET OR 30 MILES. THE OWNER'S MANUAL SAID TO TAKE IT IMMEDIATELY TO A FORD SERVICE CENTER, WHICH WE DID. THIS HAS BEEN AN ON-GOING PROBLEM SINCE WE PURCHASED THE VEHICLE IN OCTOBER, 2015. WE ONLY HAVE 1600 MILES ON SAID VEHICLE. FORD REPLACED THE ABS MODULE WHICH DID NOT HELP. FORD THEN REPLACED A RELAY AND FLOW VALVE ON THE HYDROBOOST. THIS DID NOT HELP. AT TH…

Look up ODI 10839302 at NHTSA ↗

2012 NEWMAR CANYON STAR CLASS A RV MODEL 3920 ONE OF TWO REAR TAILGATE CABLES SEPARATED ALLOWING THE REAR RAMP TO FREE FALL AT THE FORCE PROVIDED BY ITS SEVERAL HUNDRED POUND WEIGHT. THE TAILGATE NEARLY CRUSHED ME, STRIKING MY FACE, KNOCKING ME BACKWARDS ONTO THE GROUND, STRIKING MY LEFT FOOT BREAKING SEVERAL BONES. I ALSO SUFFERED A BLACK EYE. I LATER DETERMINED THAT THE THREADED CABLE BOLT COUPLING DID NOT HAVE ANY THREAD LOCK APPLIED TO THE CONNECTION ALLOWING THE COUPLING TO EVENTUALLY DETACH. UPDATED 09/25/15*LJ

Look up ODI 10746075 at NHTSA ↗

TL* THE CONTACT OWNS A 2013 NEWMAR CANYON STAR 3920 WITH A 2013 FORD F53 CHASSIS. THE CONTACT STATED THAT THE RV WAS AT STAND STILL ON THE OUTSIDE OF A PARKING LOT, WHEN OPENING THE REAR DOOR, IT DETACHED COMPLETELY AND FELL ON THE CONTACT. THE CONTACT DID NOT SUSTAINED ANY INJURIES OR SEEK MEDICAL ATTENTION. THE RV WAS TAKEN TO LOCAL DEALER WILKINS RV OF BATH LOCATED AT 7520 NY-415, BATH, NY 14810, [phone removed], WHERE IT WAS DIAGNOSED WITH NEEDING THE DOOR REPLACED. THE RV WAS TAKEN TO NEWMAR CORPORATION LOCATED AT 355 DELAWARE ST, NAPPANEE…

Look up ODI 11351200 at NHTSA ↗

Passenger side of engine valve train failure. Frozen roller bearing with heavy wear, heavy wear on cam and dropped one valve in cylinder. Major damage to cylinder wall, piston and head. Complete engine replacement needed. Only 18000 miles on this engine. Ordered new one from ford dealership. The engine has been removed by a certified ford mechanic and inspected for the damage. The motor home was not in motion when engine failure happened. There were no warning lights, messages or buzzers before during and after failure accrued. The motor was tu…

Look up ODI 11664960 at NHTSA ↗

On Friday, May 13th 2022 my wife and I were returning from a camping trip in our 2022 Canyon Star motorhome. We were getting close to home, we heard what sounded like a loud bang and the passenger side window had suddenly shattered. It appeared that the epicenter of the shatter was a circular spot behind the outside mirror about 2" from the bottom of the glass. We were not in any traffic and there were no cars near us. We did not see any debris that got kicked up at all. It appears to have just shattered for no reason. We suspect that the…

Look up ODI 11464862 at NHTSA ↗

ON MAY 3, 2021 WHILE DRIVING I-71 S IN OHIO DURING A HEAVY RAIN STORM, I EXPERIENCED A CATASTROPHIC FAILURE OF THE WINDSHIELD WIPER SYSTEM. I WAS TRAVELLING APPROX. 55 MPH. EITHER THE WIPER ARM (WHERE IT'S ATTACHED TO THE MOTOR) FAILED AND CAUSED THE BRACKET HOLDING THE MOTOR TO FAIL, OR THE BRACKET FAILED AND CAUSED THE WIPER ARMS TO FAIL. BOTH WIPERS, DRIVER'S AND PASSENGER SIDE FELL DOWN AWAY FROM THE WINDSHIELD. I WAS NOT ABLE TO SEE OUT OF THE WINDSHIELD AND HAD TO PULL OFF THE HIGHWAY.

Look up ODI 11415127 at NHTSA ↗

While stopping, a heavy knock was apparent from the forward left wheel area. This knock was speed related and was easily identified as a rotational noise. As the speed of the tire rotation decreased the knock slowed until it was identifiable as one knock per wheel rotation.

Look up ODI 11456289 at NHTSA ↗