2006 Tiffin ALLEGRO BAY: complaints, problems and recalls

MY PROBLEM DEALS WITH THE RECALL ON THE DOMETIC REFRIGERATOR THAT IS INSTALLED IN MY RV. MY REFRIG. FALLS IN THE GROUP OF AFFECTED UNITS. THE RECALL ADDRESSES REPLACING A SHIELD OVER THE GAS (FLAME) TO PROTECT AGAINST FIRE IF THE TUBE, ON THE REFRIG. CRACKS, AND LEAKS ONTO THE FLAME THEREFORE CAUSING A FIRE. I UNDERSTAND THIS, HOWEVER THIS IS NOT THE PROBLEM THE TUBE BREAKING IS THE PROBLEM AND THAT CAUSES THE FLUID TO LEAK DOWN ONTO THE GAS/FLAME. THE COMPANY TELLS ME THAT THEY ARE NOT REPAIRING THE DEFECTIVE/ CRACKED TUBES. THIS SEEMS …

Owner-reported narrative. 10,000 miles reported. Look up ODI 10290403 at NHTSA ↗

2006 ALLEGRO BAY. CONSUMER WRITES TO ACKNOWLEDGE THE VERY PROMPT AND PROFESSIONAL ASSISTANCE RENDERED WHEN HE EXPERIENCED BRAKE FAILURE *TGW THE CONSUMER RECEIVED A RECALL NOTICE IN THE MAIL REGARDING THE BRAKES. HOWEVER, THERE WAS NO PERMANENT FIX FOR THE PROBLEM. THE CONSUMER DIDN'T STATE WHICH MODEL OF THE WORKHORSE CHASSIS HE HAS. *JB

Owner-reported narrative. Look up ODI 10352090 at NHTSA ↗

THERE WAS A RECALL ON THE REFRIGERATOR IN MY MOTORHOME , PRIOR TO THE RECALL I HAD NEVER HAD A PROBLEM WITH THE REFRIGERATOR ... THE MANUFACTURER SENT SOMEONE TO THE R.V.TO PUT THE RECALL KIT ON IT AND A SHORT TIME LATER IT CAUGHT FIRE , DONE APPROXIMATELY $7000.00 OF DAMAGE TO THE UNIT.... I DEFINITELY BELIEVE THIS WAS A MANUFACTURER DEFECT PROBLEM . *TR

Owner-reported narrative. Look up ODI 10428085 at NHTSA ↗

BRAKES BECAME HOT AFTER DESCENDING A STEEP HILL. BUT DID NOT COOL OFF WHILE DRIVING ON FLAT HIGHWAY FOR 40 MILES. THEY BECAME EXTREMELY HOT AFTER 40 MILES AND PEDAL REQUIRED VIGOROUS PUMPING TO ACTIVATE AT ALL WHEN I PULLED INTO A REST AREA. THERE WAS NO INDICATION OF BRAKE FAILURE BEFORE TURNING INTO THE REST AREA BECAUSE I DID NOT HAVE TO APPLY THE BRAKES WHILE DRIVING ON THE FLAT ROAD. AFTER COOLING OVERNIGHT THE BRAKES WERE NORMAL. *TR

Owner-reported narrative. 25,500 miles reported. Look up ODI 10442879 at NHTSA ↗

AFTER EXITING INTERSTATE, STOPPING AT END OF RAMP, MAKING LEFT TURN, PROCEEDING 2 MILES THEN TURNING LEFT INTO CAMPGROUND, MY BRAKE PEDAL WENT TO THE FLOOR AND PUMPING BARELY GOT US STOPPED. UPON EXITING MH THE HOT BRAKE SMELL AND SMOKE WERE COMING FROM REAR TIRES. WE LET MH SIT FOR TIME TO COOL BRAKES SO WE COULD GET TO PARKING SPOT. EMER. ROAD SERVICE WAS CALLED AND WE WERE TOWED NEXT DAY TO REPAIR SHOP FOR MOTORCOACHES. REPAIR NEEDED WAS EXTENSIVE AND ALL ASSOCIATED BRAKE PARTS WERE REPLACED INCLUDING PADS,CALIPERS, OIL SEALS, ABS SENSORS…

Owner-reported narrative. 33,814 miles reported. Look up ODI 10458130 at NHTSA ↗

2006 ALLEGRO BAY MOTORHOME. CONSUMER WRITES IN REGARDS TO BRAKE ISSUES WITH VEHICLE *TGW THE CONSUMER STATED WHILE DRIVING 65 MPH, THE AUTO PARK WARNING LIGHT ILLUMINATED AND THEN THE BRAKE ENGAGED WHICH CAUSED THE MOTORHOME TO IMMEDIATELY COME TO A STOP. THE RV WOULD NOT MOVE UNTIL THE DRIVE SHAFT WAS REMOVED. THE RV WAS TOWED TO THE DEALER, WHERE ALL THE CONNECTIONS WERE CLEANED AND RECONNECTED AND THE WARNING LIGHT WAS TURNED OFF. ON APRIL 13, 2012 THE WARNING LIGHT ILLUMINATED AGAIN. THE PARKING BRAKE UNIT WAS REPLACED. ONCE IT WAS REPLA…

Owner-reported narrative. Look up ODI 10458370 at NHTSA ↗

THE AUTO PARK BRAKE (J72) ON MY WORKHORSE W-24 CHASSIS ACTIVATED WHILE TRAVELING 65 MPH ON ARKANSAS INTERSTATE 35 BRINGING THE VEHICLE TO A VERY ABRUPT STOP. IN RESEARCHING THE INTERNET, I HAVE FOUND THIS IS NOT A NEW PROBLEM. THIS IS A VERY DANGEROUS SITUATION, ESPECIALLY IF NO BERM WAS AVAILABLE TO PULL OFF THE HIGHWAY. AFTER BEING TOWED TO A REPAIR SHOP AND WAITING 10 DAYS FOR REPAIR, WE WERE NOTIFIED NO PARTS WOULD BE AVAILABLE UNTIL EARLY MAY. UPON RETURNING HOME (OHIO), WE HAVE DISCOVERED THERE IS CURRENTLY NO ONE MAKING THE PARTS AND M…

Owner-reported narrative. 31,159 miles reported. Look up ODI 10461453 at NHTSA ↗

TRAVELING DOWN ROAD AND SMELLED BURNING. PARKED AFTER A SHORT DISTANCE UNTIL NEXT DAY. BRAKES WERE NOT RELEASING. NEXT DAY AFTER COOLING, THE VEHICLE WAS TAKEN TO A SERVICE FACILITY, HOWEVER ADVISED BRAKES WERE FINE. APPROXIMATELY A MONTH LATER I WAS BRINGING THE VEHICLE TO A DEALER FOR AN UNRELATED MATTER. I HAD DRIVEN APPROXIMATELY 75 MILES AND WAS NEAR THE DEALER WHEN THE SAME SMELL OCCURRED. DEALER FOUND THE LEFT FRONT BRAKE CALIPER HAD FAILED. IT WAS CHANGED. APPROXIMATELY FEBRUARY OF THIS YEAR, I HAD LEFT MY HOUSE AND TRAVELED APPROXIMATE…

Owner-reported narrative. 24,800 miles reported. Look up ODI 10465357 at NHTSA ↗

Reported: 2008-10-07 (October 7, 2008)

TIFFIN IS RECALLING 3,507 MY 2004-2007 ALLEGRO, ALLEGRO BAY AND ALLERO BUS, MY 2004-2005 PHAETON AND MY 2005-2007 ZEPHYR MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy: TIFFIN WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR TIFFIN AT 256-356-8661.

Reported: 2009-04-03 (April 3, 2009)

NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Consequence: THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Remedy: WORKHORSE DEALERS WILL REPLACE ALL FOUR BOSCH BRAKE CALIPER ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2010. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.

Reported: 2011-06-15 (June 15, 2011)

TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2006-2010, ALLEGRO AND ALLEGRO BAY RECREATIONAL VEHICLES, MANUFACTURED FROM JANUARY 2005, THROUGH APRIL 2010, AND BUILT ON A DAIMLER/FREIGHTLINER CHASSIS. THE BRAKE LIGHTS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS.

Consequence: THE BRAKE LIGHTS MAY NOT ILLUMINATE CONSISTENTLY UPON BRAKE APPLICATION AND FAIL TO PROPERLY INDICATE TO A FOLLOWING VEHICLE THAT THE MOTORHOME HAS SLOWED OR COME TO A STOP, INCREASING THE RISK OF A CRASH.

Remedy: DAIMLER TRUCKS (DTNA), MANUFACTURER OF THE CHASSIS, WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DTNA DEALERSHIPS, FREE OF CHARGE. (SEE DTNA'S RECALL CAMPAIGN 10V-178.) THE SAFETY RECALL BEGAN ON MAY 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Reported: 2012-06-19 (June 19, 2012)

TIFFIN IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 ALLEGRO AND ALLEGRO BAY RECREATIONAL VEHICLES EQUIPPED WITH BOSCH HYDRAULIC BRAKES. HYDRAULIC BRAKE EQUIPPED MOTORHOME CHASSIS EXPOSED TO LONG PERIODS OF TIME OF NON-DRIVING MAY EXPERIENCE DIAMETRICAL BRAKE CALIPER PISTON GROWTH AND REDUCED PISTON TO BORE CLEARANCE POTENTIALLY LEADING TO BRAKE DRAG AND OVERHEATING RESULTING IN REDUCED BRAKE PERFORMANCE.

Consequence: REDUCED BRAKE PERFORMANCE MAY LEAD TO AN INCREASED RISK OF A CRASH.

Remedy: TIFFIN WILL NOTIFY THE OWNERS, AND AUTHORIZED DAIMLER TRUCKS NORTH AMERICA (DTNA) DEALERS WILL INSPECT AND, AS NECESSARY, REPLACE THE BRAKE CALIPERS FREE OF CHARGE. AN INTERIM NOTICE WAS MAILED TO OWNERS BY DTNA ON AUGUST 6, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.